An Impervious Diaphragm in Earth Dams.

As a result of the recent extended discussion concerning the design of the New Croton Dam and the Jerome Park Reservoir embankments, the Engineering News of Feb. 20, 1902, contained a very suggestive editorial entitled, “Concerning the Design of Earth Dams and Reservoir Embankments.” The opinion is given that no type of structure that man builds to confine water can compare in permanence with earth dams, after which the following pertinent questions are asked:

1. How shall an earth dam be made water-tight?

2. What is the office and purpose of the masonry core wall?

3. Would not a water-proof diaphragm of some kind be better than a core wall of either masonry or puddle?

The article then suggests a number of designs of diaphragm construction, with a special view of obtaining absolute water-tightness, by use of asphaltum, cement mortar, steel plates, etc. Special emphasis was put upon the principle of constructing a water-proof diaphragm. The matter of relative cost is advanced as an argument in favor of the diaphragm principle as against the usual orthodox method. The saving in cost is to be accomplished by the use of inferior materials and less care in the handling of them, or by both. It is suggested that almost any kind of material available, rock, sand or gravel, will answer every purpose where good earth is not to be found. Further, that this material may be dumped from the carts, cars or cableways, or be placed by the hydraulic-fill method.

The writer believes the diaphragm method of construction may have some merits, but that it is attended by the very great risk of neglecting principles most vitally important to the successful construction of high earth dams, which will now be formulated and advanced, as follows:

CHAPTER VI.
Conclusions.

The writer in concluding this study wishes to emphasize certain principles and apparently minor details of construction, which from observation and personal experience, seem to him of vital importance.

He believes firmly in the truth contained in the following remarks by Mr. Desmond FitzGerald, of Boston, germane to this subject:

An engineer must be guided by local conditions and the resources at his command in building reservoir embankments. His design must be largely affected by the nature of the materials. There are certain general principles, however, which must be observed and which will be applied by an engineer of skill, judgment and experience to whatever design he may adopt. It is in the application of these principles that the services of the professional man becomes valuable, and it is from a lack of them, that there have been so many failures.

The details and principles of construction, relating to high earth dams, may be summarized or stated in order of their application, as follows:

(1) Select a firm, dry, impermeable foundation, or make it so by excavation and drainage. All alluvial soil containing organic matter and all porous materials should be excavated and removed from the dam site when practicable; that is, where the depth to a suitable impermeable foundation is not prohibitive by reason of excessive cost.

Wherever springs of water appear, they must be carried outside the lines of the embankment by means of bed rock drains, or a system of pipes so laid and embedded as to be permanent and effective.

The drainage system must be so designed as to prevent the infiltration of water upward and into the lower half of the embankment, and at the same time insure free and speedy outlet for any seepage water passing the upper half. All drains should be placed upon bed rock or in the natural formation selected for the foundation of the superstructure. They should be constructed in such a manner as to prevent the flow of water outside the channel provided for it, and also prevent any enlargement of the channel itself. To this end, cement, mortar, broken stone, and good gravel puddle are the materials best suited for this purpose.

(2) Unite the body of the embankment to the natural foundation by means of an impervious material, durable and yet sufficiently elastic to bond the two together. When the depth to a suitable foundation is great, a central trench excavated with sloping sides, extending to bed rock or other impervious formation, refilled with good puddling material, properly compacted, will suffice.

When clayey earth is scarce and expensive to obtain, a small amount of clay puddle confined between walls of brick, stone or concrete masonry, and extending well into the body of the embankment and so built as to avoid settlement, will prevent excessive seepage. This form of construction is not to be carried much above the original surface of the ground.

(3) The continuity of surfaces should always be broken, at the same time avoiding the formation of cavities and lines of cleavage. No excavation to be refilled should have vertical sides, and long continuous horizontal planes should be intercepted by wedge-shaped offsets, enabling the dovetailing of materials together.

All loose and seamy rock or other porous material should be removed, and where the refill is not the best for the purpose, mix the good and bad ingredients thoroughly, after which deposit in very thin layers.

(4) Make the dimensions and profile of dam with a factor of safety against sliding of not less than ten. The preliminary calculations for designing such a profile have been given on [p. 42].

(5) Aim at as nearly a homogeneous mass in the body of the embankment as possible, thus avoiding unequal settlement and deformation. This manner of manipulating materials will eliminate many uncertain or unknown factors, but it means rigid inspection of the work and intelligent segregation of materials, no matter what method of transporting them may be adopted. The smaller the unit loads may be, the more easily a homogeneous distribution of materials will be obtained.

(6) Select earthy materials in preference to organic soils, with a view of such combination or proportion of different materials as will readily consolidate. Consolidation is the most important process connected with the building of an earth dam. The judicious use of soil containing a small percentage of organic matter may be permitted, however, when there is a lack of clayey material for mixing with sandy and porous earth materials. Such a mixture, properly distributed and wetted, will consolidate well under heavy pressure and prove quite satisfactory.

(7) Consolidation being the most important process and the only safeguard against permeability and instability of form, use only the amount of water necessary to attain this. Too much or too little are equally bad and to be avoided. It is believed that only by experiment and experience is it possible to determine just the proper quantity of water to use with the different classes of materials and their varying conditions. In rolling and consolidating the bank, all portions that have a tendency to quake must be removed at once and replaced with material that will consolidate; it must not be covered up, no matter how small the area.

(8) In an artificial embankment for impounding water it is impracticable to place reliance upon time for consolidation; it must be effected by mechanical means. Again we repeat, that consolidation is the most vitally important operation connected with the building of an earth dam. When this is satisfactorily attained it is proof that the materials are suitable and that the other necessary details have been in a large measure complied with. Light rollers are worse than useless, being a positive harm, resulting in a smoothing or “ironing process,” deceptive in appearance and detrimental in many ways.

The matter of supreme importance in the construction of earth dams is that the greatest consolidation possible be specified and effected. To this end it is necessary that heavy rollers be employed, and that such materials be selected as respond best to the treatment. There are certain kinds of earth materials which no amount of wetting and rolling will compact. These must be rejected as unfit for use in any portion of an earth dam. Let the design of the structure be ever so true to correct engineering principles, it is still necessary to give untiring attention to the work of consolidation. It is therefore according to the design of a thoroughly compacted homogeneous mass, rather than to the suggested diaphragm type, to which modern practice should conform. This is in harmony with Nature’s own methods, and in conformity to correct principles.

(9) Avoid placing pipes or culverts through any portion of the embankment. The writer considers it bad practice ever to place the outlet pipes through a high earth dam, and fails to see any necessity for so doing.

(10) The surface of the dam, both front and rear, must be suitably protected against the deteriorating effects of the elements. This may include pitching the up-stream face, the riprap work at the toe of the inner slope, the roadway and covering of the crown, the sodding or other protection of the rear slope, and the construction of surface drains for the berms.

(11) Ample provision for automatic wasteways should be made for every dam, so that the embankment can never under any circumstances be over-topped by the impounded water. Earthquakes and seismic disturbances will produce no disastrous effects upon an earth dam. Its elasticity will resist the shock of water lashing backwards and forwards in the reservoir.

(12) Finally, provide for intelligent and honest supervision during construction, and insist upon proper care and maintenance ever afterwards.

APPENDIX I.
High Earth Dams.

|–Embankment–||––– Slopes –––|Available
depths,
ft.
Name of Dam
or Reservoir.
Location.Max.
height,
Top
width,
Water.Bear.
ft.ft.
San LeandroCalifornia12528
TabeaudCalifornia123203 on 12½ on 170
Druid HillMaryland119604 on 12 on 182
DodderIreland115223½ on 13 on 1
Titicus DamNew York110302 on 12½ on 1
Mudduk TankIndia108 3 on 12½ on 1
Cummum TankIndia102 3 on 11 on 190
Dale DikeEngland102122½ on 12½ on 1
MarengoAlgeria101
TorsideEngland100 84
YarrowEngland100243 on 12 on 1
Honey LakeCalifornia96203 on 12 on 1
PilarcitosCalifornia95252¾ on 12½ on 1
San AndresCalifornia95253½ on 13 on 1
TemescalCalifornia95123 on 12 on 1
WaghadIndia9563 on 12 on 181
BradfieldEngland95122½ on 12½ on 1
Oued MenradAlgeria95
St. AndrewsIreland9325
EdgelawScotland93 3 on 12½ on 1
WoodheadEngland90 72
TordoffScotland85103 on 12½ on 1
NaggarIndia84
VaharIndia84243 on 12½ on 1
RoseberyScotland84
AtlantaGeorgia8240
RoddlesworthEngland80163 on 12½ on 168
GladhouseScotland79123 on 12½ on 1 68½
RakeEngland78 3 on 12 on 1
SilsdenEngland78 3 on 12 on 1
GlencourseScotland77 3 on 1 58
LeeshawEngland77
WayohEngland76223 on 12½ on 1
Ekruk TankIndia76203 on 12 on 165
NehrIndia748
Middle BranchNew York73
LeemingIreland73103 on 12 on 150
South ForkPenna.72202 on 11½ on 150
AnasagurIndia70204 on 1
PangranIndia688 42
HarlawScotland67 64
Lough VartryIreland66283 on 12½ on 160
La MesaCalifornia66201½ on 11½ on 160
AmsterdamNew York65
MuktiIndia65103 on 12 on 141
Snake RiverCalifornia64122 on 11½ on 1
StubkenIreland63243 on 12 on 1
Den of OgilScotland60 50
LoganleaScotland59103 on 12½ on 155
AshtiIndia5863 on 12 on 142
Cedar GroveNew Jersey55183 on 12 on 150

APPENDIX–II.
Works of Reference.

Author.Title. Date.
Baker, Benj.The Actual Lateral Pressure of Earthwork1881
Baker, Ira O.Treatise on Masonry Construction1899
Bell, Thos. J.History of the Water Supply of the World1882
Beloe, Chas. H.Beloe on Reservoirs1872
Bowie, Aug. J., Jr.A Practical Treatise on Hydraulic Mining1898
Brant, Wm. J.Scientific Examination of Soils1892
Brightmore, A. M.The Principles of Water-Works Engineering1893
Buckley, Robt. B.Irrigation Works in India and Egypt1893
Cain, Wm.Retaining Walls1888
Chittenden, H. M.Report and Examination of Reservoir Sites
 in Wyoming and Colorado1898
Courtney, C. F.Masonry Dams1897
Fanning, J. T.Water-Supply Engineering1889
Flynn, P. J.Irrigation Canals and Other Irrigation Works1892
Frizell, Jos. P.Water Power1891
Gordon, H. A.Mining and Mining Engineering1894
Gould, E. S.The Elements of Water-Supply Engineering1899
Hall, Wm. Ham.Irrigation in California1888
Hazen, AllenThe Filtration of Public Water Supplies1895
Howe, M. A.Retaining Walls for Earth1891
Hughes, Saml.Treatise on Water-Works1856
Jackson, L. D. A.Statistics of Hydraulic Works1885
Kirkwood, J. P.Filtration of River Waters1869
Merriman, M.Treatise on Hydraulics, Masonry Dams
 and Retaining Walls1892
Newell, F. H.Irrigation in the United States1902
Newman, JohnEarthwork Slips and Subsidences Upon
 Public Works1890
Potter, ThomasConcrete1894
Schuyler, J. D.Reservoirs for Irrigation, Water Power
 and Domestic Water Supply1901
Slagg, Chas.Water Engineering1888
Stearns, F. P.Metropolitan Water-Works Reports1897
Stockbridge, H. E.Rocks and Soils1888
Trautwine, J. C.Earthwork; and Engineer’s Pocket-Book1890
Turner, J. H. T.The Principles of Water-Works Engineering1893
Wilson, J. M.Manual of Irrigation Engineering1893

Annual Reports.