Engraved Negatives for Photo-lithography.

In certain processes for the production of photo-relief blocks many operators prefer artificial negatives, in the production of which photography has played no part, but which are, on the contrary, the direct production of the artist’s hand.

Factitious Negatives may be produced by coating a plate with a transparent but non-actinic coating, and by removing or erasing in a suitable manner designs may be copied without the use of a camera or lens. Professor Husnik and others have published different methods whereby the artist is enabled to transfer the creations of his pencil to zinc or stone, without resorting to the aid of the photographic negative process, although the subsequent operations may still entitle it to be styled photo-lithography.

The process most likely to lead to success consists of first coating a glass plate with a strongly iodised collodion, sensitising as usual, well washing on both sides and drying. To engrave, lay the plate upon a black cloth, and the design may be traced and engraved upon the surface by means of etching points or needles. Remove all loose particles of collodion from the plate by gentle brushing when the drawing is completed. Immerse the plate a second time in the silver bath, and develop with either pyrogallic acid or sulphate of iron developer.

Husnik proposes to first coat the plate with a solution of pure fuchsin, and afterwards with one of gum, and then engrave as previously indicated.[Y]

[Y] Major Waterhouse has published the following ingenious method of transforming a drawing on paper into a photographic negative:—“A tracing, or drawing, is made in lithographic ink on tracing paper, using plenty of ink on the lines. The drawing is then placed on a board over a piece of blotting-paper, and brushed all over with a strong solution of aniline brown in water; when dry it is rubbed over with a tuft of cotton wool soaked in turpentine, which removes the ink without altering the coloured ground. The lines then appear clear on a dark reddish brown ground. The negatives thus obtained are good, but more suited for coarse than fine work.” It may be suggested, why not transfer the drawing direct to stone, and produce the necessary copies by lithography?—Trans.

By either of these methods negatives of extreme density and absolute clearness in the lines may be produced and used for obtaining impressions in ink, the transfer of which to stone presents no difficulty.

It remains to be added that there are several methods of producing grained negatives for photo-lithography in half-tone, and therefrom a transfer for stone, and so obtaining impressions at a much greater rate than is possible from a Collotype plate. They may each produce results with a certain amount of success; but even those from the best methods indicated cannot be compared with Collotype. The too obtrusive grain of the half-tone pictures so produced destroys much of the finer details, and it is to be regretted that all such processes leave so much to be desired.

APPENDIX.

THE STEAM COLLOTYPE MACHINE.

THE earliest steam machines for Collotype printing were made by Faber & Co., of Offenbach; they were, however, so complicated and delicate in construction that other machines have entirely supplanted them. The three principal varieties are those of Alauzet & Co., of Paris; Koch, of Leipzig; and Schmiers, Werner & Stein, each of which may be considered entirely successful; they possess features of great similarity, differing not in principle, but only in details of construction. Contrasting the work of the machine with that of the press, the printing is much more rapid, and the prints more uniform and regular, while the “life” of the plate is greatly lengthened; one capable of yielding 250 impressions on the scraper press would, in all probability, give 1,000 on the machine—a fact easily accounted for when it is considered that the one is produced by a scraping pressure while the other is made by the rotation of a cylinder. As will be seen by the illustrations, the machines bear a considerable resemblance to those used in lithography—they may, in fact, be used for lithographic printing—with very greatly increased inking power. The machines are so constructed that the plate may be inked once, twice, or three times, each inking giving more vigour, but, of course, a corresponding decrease in the number of impressions yielded; the output may be relatively estimated at 1,500, 1,000, and 800 per day. It is, of course, an impossibility to teach machine printing by means of instructions such as may be conveyed in a work like the present, and the following remarks are added more with a view of giving a general idea of the nature of the necessary operations than with any idea of making the reader a competent machine minder.

The Preparation of the Plate for the machine is identical with its preparation for the hand-press, but greater uniformity, both in the negative, exposure, and etching, are demanded than by the hand-press. For the latter considerable latitude is permissible, as the intelligent printer may, by varying his rollers, his rate of rolling and other little dodges, produce perfect impressions from plates which would, under the entirely mechanical action of the machine, fail lamentably.

Adjustment of the Rollers is so effected that they are lifted about 2 mm. when passing over the inking slabs and the printing plate; if a greater lift is necessary to bring them upon the printing surface marks will be produced upon the plate, and if arranged for a less lift they will probably skid over the plate, damaging the printing surface. They should also be adjusted perfectly parallel with the surface of the inking tables, or one side only may come in contact with the work.

Fixing the Plate to the bed of the machine is effected in several ways, but usually with small clips, as described for the hand-press. All adhering gelatine, etc., must be removed from the plate, and a thin sheet of white paper inserted between it and the bed of the press. The faces of the metal clips must be protected with strips of leather, cork, or some such elastic bodies, otherwise the pressure exerted would cause the glass to fly. A straight edge is placed across the machine, and the bed lowered by means of inclined planes attached to suitable gearing until the surface of the plate is well below the circumference of the cylinder, and from this position it is brought up to its proper level, raising each side equally, that the pressure may be perfectly uniform.

Packing the Cylinder.—The cylinders are so constructed that the iron surface does not come in actual contact with the printing paper. In fact, there is a deficiency between the actual and necessary diameter of the cylinder of a few mm., sometimes as much as 7 mm. This is compensated for by the addition to its surface of “packing,” which gives a more elastic pressure than the unyielding surface of iron. This packing is not applied to the entire surface of the cylinder, but is so devised that it exerts pressure upon the surface of the picture only. A sheet of smooth four-ply cardboard is attached to the cylinder by means of thin glue, this first sheet usually exceeding the size of the picture. To this is attached a second piece, cut of the exact size of the image, and attached by means of the glue, forming a raised block in exact register with the position of the picture on the printing plate; this is covered with a thickness or two of fine blotting-paper, and over the whole the sheeting of the cylinder is tightly stretched in the usual well-known manner. It is self-evident that the circumference of the cylinder must traverse at exactly the same speed as the bed of the machine, or there will be a horizontal rubbing or friction between the surface of the printing paper and that of the printing layer, which will result in impressions lacking in sharpness, and ultimate destruction of the plate.

Masking the Prints for the production of white margins is usually performed by one of two methods, each having advantages and disadvantages which should be carefully considered before adopting either; both are in practical use. In one is used a light rectangular iron framework or “frisket,” conforming to the size of the cylinder, to which it is attached by hinges. This framework is opened and closed automatically, remaining open during the period the cylinder is resting and the inking is taking place. At this point the “layer-on” inserts the paper, it is seized by the grippers, and the masking frame closes down into suitable grooves in the circumference of the cylinder, such grooves being useful to prevent any lateral movement of the frame. To the latter are attached four movable strips of thin zinc, which may be adjusted by means of set screws to form an opening of any desired size. The printing paper being inserted in the grippers, the frame closes, holding the paper upon the cylinder, the strips of zinc at the same time protecting the edges of the paper from immediate contact with the printing layer, the cylinder revolves, and the printing is effected. In large sizes the zinc strips are necessarily of such strength that the edges would cut and damage the printing layer; it is therefore usual to adjust the strips to within about 5 mm. of the edges of the picture, and by attaching strips of varnished tissue paper to the zinc, reducing the aperture to the size of the picture in hand. In large sizes—where thin paper is used, or where narrow margins are desired—this system of masking is best, as the whole of the operation is entirely automatic. The layer-on may devote the whole of his attention to removing impressions and inserting fresh paper.

Another System of masking frequently made use of is one in which an aperture of suitable size is cut in a piece of cardboard, such aperture being, say, 2 mm. larger than the print. The portion removed is reduced in size by 2 mm. all round, leaving it exactly the size of the impression desired. This piece is utilised for packing by attaching to the cylinder as previously described. The cardboard mask, presenting the exact appearance of a sunk mount, is affixed by means of a bar to the cylinder, and when folded down upon the latter, the “cut out” used as packing exactly occupies the centre of the mask, leaving a marginal space all round of 2 mm. Before printing, the mask must be varnished with negative varnish, bitumen in benzol, or otherwise waterproofed, to prevent adhesion to the print layer. The mask has to be turned back by hand at the insertion of each sheet—a considerable disadvantage when compared with the automatic frame. On the other hand, its advantages are simplicity of preparation, and the possibility it allows of masking and printing several irregularly-disposed pictures on one sheet.

Damping the Plate.—The use of the cylinder pressure has further advantages than merely prolonging the life of the plate—the operation of damping is much less needed than on the hand-press. The printing paper does not come in contact with the plate before the instant of printing or remain upon it after the operation, but is held to the cylinder by the grippers and mask, and so carried over the inked plate, consequently little opportunity is afforded for absorption of the etching fluid. With chalk paper and a new plate damping may be necessary every twenty-five impressions, but as the plate becomes older fifty or even one hundred may be printed between the etchings. On plain paper of hard surface much longer numbers may be expected.

The Inking Tables, two in number, are provided one at either end of the machine, necessitating two sets of inking rollers—one of leather for applying the thick ink, and another of composition for supplying the “half-tone,” the latter set requiring such light application to the plate that no riders are required. There are also the usual distributing rollers, to which the ink is generally supplied by the printer as may be necessary, the quantity being so small that no actually satisfactory automatic duct has yet been devised. A proper adjustment of the consistency of the two inks to the requirements of the plate in hand is a matter of considerable delicacy, for should the ink supplied to the leather rollers be too thin it is immediately removed from the printing plate by the composition rollers; these again transfer it to the table devoted to the thin ink, and a general “wash up” is the necessary result. The ink first supplied to the leather rollers should be as stiff as possible, afterwards reducing as experience may dictate, while to the composition or tone rollers merely coloured varnish, or even varnish alone, is applied, as the latter often remove enough colour from the printing plate to sufficiently tint the varnish applied to their surface. The leather rollers should be cleaned daily by scraping, and the composition set washed, unless the weather be very cold or damp. In such cases they may be allowed to stand under ink, as they will in that condition be less susceptible to atmospheric changes.

Double Printing is sometimes resorted to for work of a high class, and when negatives too thin to produce good results otherwise are unavoidably used, such work is usually printed on chalk paper and without masking. The printing plate is usually inked up twice and an impression taken; without removing the impression from the cylinder the plate is again twice inked and a second impression pulled on the same piece of paper, the two images being exactly super-imposed. The great gain in contrast will be understood when it is considered that while the high lights of the picture gain absolutely nothing, the strength of the shadows is exactly doubled. The results produced in this way are simply astonishing when contrasted with silver prints from the same negatives.

ADVERTISEMENTS.

HUGO KOCH,

LEIPZIG-CONNEWITZ, GERMANY,

MANUFACTURER OF

Collotype Steam Presses.

Awarded First Prizes at all Exhibitions where our Presses have competed.

World’s Exhibition, Antwerp, 1885, Diploma of Honour.

THE
KOCH COLLOTYPE STEAM PRESS IS THE BEST IN THE MARKET

MADE IN FOUR SIZES.

AUTOMATIC FEED BOARD, FRISKET, AND INK DUCT.

If desired, the press can be arranged also for litho or type printing

***That these machines have been adopted, to the exclusion of all others, in establishments of such repute as those of Albert, of Munich, and the “Phototypisches Institute” of Berlin, are facts of the greatest significance.

PRICES AND PARTICULARS ON APPLICATION TO

HUGO KOCH, Leipzig-Connewitz, GERMANY,

OR

BEESLEY & CO., YORK PASSAGE, BIRMINGHAM.

SCHMIERS, WERNER AND STEIN,

MANUFACTURERS OF
PRINTING MACHINERY

OUR COLLOTYPE MACHINES have now been introduced for upwards of twelve years, during which period they have been adopted by the most renowned Collotype establishments in all countries.

They are manufactured in four sizes, with all recent improvements, and may be ordered either with or without masking frames, the utmost satisfaction being guaranteed.

They may be utilised for Lithographic Printing.

Further information in reply to all questions on application to

SCHMIERS, WERNER & STEIN,
DÖSENER WEG, LEIPZIG.

ESTABLISHED 1823.

BERGER & WIRTH,

LEIPZIG, GERMANY,

Ink Manufacturers.

SPECIALITIES—

COLLOTYPE INKS

In all Shades.

PRICES AND SAMPLES

FORWARDED UPON APPLICATION.

THE MAWSON

“Photo-Mechanical” Plates

ARE SPECIALLY MADE FOR

Collodions, Varnishes, Chemicals, and other requisites for Photo-Engravers, etc.

MAWSON & SWAN,
33, SOHO SQUARE, LONDON, W.,

AND

15, Mosley Street, NEWCASTLE-ON-TYNE.

GELATINE.

NELSON’S PHOTOGRAPHIC GELATINE
IS RECOGNISED AS
THE BEST for all Photographic purposes.

Nelson’s “Special X Opaque,” for Dry Plates.

Sold Retail by all Dealers in Photographic Materials. Wholesale by the Manufacturers—

GEO. NELSON, DALE and CO., LIMITED,

14, DOWGATE HILL, LONDON, E.C.

EASTMAN’S
STRIPPING FILMS

Produce the most perfect Reversed Negatives for Collotype and Photo-Lithography, and, when used in EASTMAN’S ROLLER SLIDES, reduce the bulk and weight immensely.

EASTMAN’S PERMANENT BROMIDE PAPER.
EASTMAN’S TRANSFEROTYPE PAPER.

The Eastman Dry Plate & Film Co.,
115, OXFORD STREET, LONDON, W.

AN INTRODUCTION TO

THE

SCIENCE AND PRACTICE

OF PHOTOGRAPHY:

BY
CHAPMAN JONES, F.I.C., F.C.S.,

Demonstrator of Practical Chemistry in the Normal School of Science and Royal School of Mines;
Member of the Photographic Society of Great Britain, &c.

Cloth, price 3/6; post free, 3/10-1/2. Paper Covers, 2/6; post free, 2/10-1/2;

ILIFFE & SON, 3, St. Bride St., Ludgate Circus, London, E.C.

THE BEST FIRST BOOK FOR PHOTOGRAPHERS TO BE HAD.

PHOTOGRAPHY FOR ALL:

An Elementary Text Book and Introduction to the Art of Taking Photographs;

BY
W. JEROME HARRISON, F.G.S.,

Author of “A History of Photography,” and European Editor of “The International Annual of Anthony’s Photographic Bulletin.”

PRICE ONE SHILLING. Post free, 14 Stamps.

LONDON: ILIFFE & SON, 3, St. Bride St., Ludgate Circus.

ALL ARTICLES FOR

COLLOTYPE, PHOTO-LITHOGRAPHY, AND ETCHING PROCESSES,

AS

PRESSES, PAPERS, INKS, ROLLERS, CHEMICALS, &c.
MAY BE OBTAINED THROUGH

ROMAIN TALBOT, Brüderstrasse 10, BERLIN C.

SPECIAL GENERAL PRICE LIST GRATIS ON DEMAND.

E. T. GLEITSMANN

(Established 1851.) DRESDEN, (Established 1851.)

INK MANUFACTURER.

SPECIALITY—

BLACK & COLOURED COLLOTYPE INKS

AND

Composition for Collotype Rollers.

F. DRESCHER & CO.,

GELATINE WORKS,

OBERNDORF, Schweinfurt a/ Main, GERMANY,

MANUFACTURERS OF

Special Gelatines for all Photographic purposes.

THE INDISPENSABLE HANDBOOK
TO
The Optical Lantern:

A COMPLETE CYCLOPÆDIA ON THE SUBJECT OF

OPTICAL LANTERNS, SLIDES, AND ACCESSORY APPARATUS.

Compiled by
WALTER D. WELFORD.

Edited by
HENRY STURMEY.

CONTENTS.

SECTION I.

Part 1.—The Cheaper Oil Lanterns. Better Class Oil Lanterns. Double or Dissolving Oil Lanterns.

Part 2.—Single Limelight Lanterns. Biunials. Triunials. Special Lanterns.

Part 3.—Scientific Lanterns.

SECTION II.

Part 1.—Illuminants—Lamps, Jets, and Accessories.

Part 2.—Lenses, Condensers, &c.

Part 3.—Gas, Apparatus, Retorts, Purifiers, &c. Bags, Cylinders, Valves, Pressure Boards, &c.

Part 4.—Exhibition. Screens. Screen Frames. Reading Lamps. Desks. Tripods. Boxes. Tables, &c.

Part 5.—Accessories. Microscope. Polariscope. Aphengescope, &c.

SECTION III.

Part 1.—Carriers. Frames. Tinters, Registering Apparatus, Grooved Boxes, &c.

Part 2.—Slide Makers and Slide Painters—Notices of their Productions and Specialities.

Part 3.—Slides—Temperance, Tales, Scriptural, Scenery, Nursery Tales, Historical, Entertainments, Pantomimes, Educational, Comic, Movable, Effect and Dissolving, Mechanical.

SECTION IV.

General Articles.—Hints to Lecturers, by Andrew Pringle; and other articles

400 PAGES. NUMEROUS ILLUSTRATIONS.

PRICE 2/6; post free, 2/10-1/2.

London: ILIFFE & SON, 3, St. Bride St., Ludgate Circus.

KLIMSCH & Co.,
FRANKFORT-ON-THE-MAIN, GERMANY.

MANUFACTURERS AND AGENTS FOR ALL
Special Materials AND Requisites
FOR
COLLOTYPE & PHOTO-LITHOGRAPHIC PROCESSES.

COLLOTYPE MACHINES,
ROLLERS, COLORS, INKS
Printing and Transfer Papers, &c.

WE FURNISH ENTIRE STUDIOS AT ADVANTAGEOUS RATES

Write for particulars and Price Lists.

An unequalled guide to the latest Developments and Processes.

THE INTERNATIONAL ANNUAL

Anthonys Photographic Bulletin.

EDITED BY
W. JEROME HARRISON, F.G.S., AND A. H. ELLIOTT, PL.O.

PRICE 2/-; post free 2/4-1/2.

ILIFFE & SON, 3, ST. BRIDE STREET, LONDON, E.C.

A GREAT DIFFICULTY,

And one experienced by all photo-mechanical experimentalists, has been that of obtaining SUITABLE and RELIABLE material and appliances. A prolonged visit to the best known photo-mechanical establishments of Austria and Germany enables us to guarantee that the articles we recommend are the best obtainable for the purposes for which they are supplied. We are in a position to supply—

COLLOTYPE:

Collotype Machines—Hand Presses—Drying Boxes—Inks—Varnishes—Printing and Masking Papers—Leather, Rubber and Composition Rollers—Gelatine Plates—Iron Beds for Presses—Printing Frames—Reversing Mirrors and Prisms, &c., &c.

ZINC ETCHING:

Zinc Plates—Etching and Tapping Inks—Rollers—Etching Boxes—Transfer Papers—Printing Frames—Scratch Papers—Whirlers—Ruled Tints, &c.

PHOTO-LITHO.

SOLE AGENTS FOR

Jaffé & Albert’s Transfer Ink and Papers.

The only Photo-transfer Paper to which a GOLD MEDAL has ever been awarded.

USED ALMOST EXCLUSIVELY ON THE CONTINENT.

BEESLEY & CO.,
York Passage, BIRMINGHAM.

THE PHOTOGRAPHERS’ INDISPENSABLE HANDBOOK:

A COMPLETE CYCLOPÆDIA OF

Photographic Apparatus, Material AND Processes

COMPILED AND EDITED BY

W. D. WELFORD and HENRY STURMEY.

THIS work aims at being for size and weight the most PRACTICALLY USEFUL of any publication on Photography yet issued. No practitioner, whether professional or amateur, whose time is of the slightest value, should fail to possess a copy. It consists of 422 handsomely printed pages, demy 8vo., and 500 illustrations, crammed full of information, the result of several months’ steady labour. Descriptions and prices of every photographic accessory, over 200 cameras, 150 lenses, 40 tripods and stands, 140 plates, 40 lamps, shutters, complete sets, burnishers, special solutions, etc., etc., etc. Numerous press and other opinions sent on application.

“Will prove of great assistance.”—Proceedings of the Camera Club.

“The Laxton of the Photographer.”—Photographic News Almanac.

“This is an excellent guide to the purchaser of Photographic Apparatus.”—The Camera.

PRICE, 2/6; post free, 2/10-1/2.

ILIFFE & SON, 3, St. Bride St., Ludgate Circus, LONDON, E.C.

CH. LORILLEUX & CO.,

Printing Ink Manufacturers

BLACK AND COLOURED VARNISHES, ROLLER COMPOSITION, ETC.

SPECIAL INKS for COLLOTYPE

GOLD MEDALS.

PARIS 1855.

PARIS 1878.

MELBOURNE 1881.

LONDON 1884.

DIPLOMAS OF
HONOUR.

VIENNA 1873.

AMSTERDAM 1883.

ANTWERP 1884.

PARIS: 16, Rue Suger. LONDON: 27, Bouverie St., Fleet St.

Works: Puteaux and Nanterre.

To Collotypists

We strongly recommend our
ROSE-TINTED DULL ENAMEL PAPER.

Quality the Best.

Samples and Proofs on application.

Gust. & Heinr. Beneke,
Löban, Saxony.

HEINRICHS’
CELEBRATED
GELATINES

FOR

Photo-Lithography, Collotype,

—ETC.—

A. & M. ZIMMERMANN

SOLE AGENTS,
6 & 7, Cross Lane,
LONDON, E.C.,

Or direct from the Manufacturer—

CH. W. HEINRICHS,
Gelatine Works, Hoechst-on-the-Main,
GERMANY.

The OLDEST Penny Photographic Paper in the World.

EVERY THURSDAY—ONE PENNY.

PHOTOGRAPHY:

The Journal of the Amateur, the Profession, and the Trade,

IS

ACCURATE, NEWSY, ENTERPRISING.

EDITORIAL CONTRIBUTORS—
Capt. W. de W. ABNEY, C.B., F.R.S.; Prof. W. K. BURTON, C.E.; GEORGE DAVISON; CHAPMAN JONES; ANDREW PRINGLE; FRANK M. SUTCLIFFE.

Editor—HENRY STURMEY.

Sub-editor—WALTER D. WELFORD.

The special features are:—Scientific and Technical Articles by well-known writers—The Question Box, with a series of prizes for the senders of replies—Prize Competitions—Snap Shots—Items of Interest—Interviews with Prominent Members of the Trade; and the price—One Penny.

A SPECIMEN COPY WILL BE SENT GRATIS AND POST FREE.

WHAT THEY THINK OF IT:

“Photography is a positive success.”—Wilson’s Photographic Magazine.

“A stirring, newsy journal, which bids fair to a successful career.”—St. Louis Photographer.

“It is very interesting, and far ahead of the other photographic papers.”—Gerald Stoney, Gateshead.

“I look upon Photography now as part of my weekly diet, as it suits my constitution.”—Moore, Dartford.

“When I have read the pages of one week’s issue I am anxious to see the next.”—F. Lewis, Derby.

“Your new journal, like the ‘Pickwick’ pen, ‘comes as a boon and a blessing to men.’”—J. C. Christie, Old Cathcart.

“You may be sure I shall prize this, my first silver medal, and I shall not want to look at it to remind me of Photography, as I always have this paper for dessert on Thursdays.”—J. W. Evans, Wolverhampton.

“I think your paper a marvel of cheapness. I had great difficulty in getting it regularly, or even at all, at first; but since I have succeeded I think all my early trouble has been liberally repaid.”—A. C. Anderson, Arbroath.

“I must say Photography is proving a decided success; it seems to be improving every week. Since taking in your paper I have entirely given up a journal which is published on the same subject, which, though more mature in years, still takes a leaf from its infant friend.”—M. Tillicouthy.

London: ILIFFE & SON, 3, St. Bride St., E.C.

AND ALL BOOKSELLERS AND BOOKSTALLS

Editorial and Advertisement Offices: VICAR LANE, COVENTRY.

Transcriber’s Note:

Punctuation has been standardised. Spelling and hyphenation have been retained as they appear in the original publication except as follows: