FIREWORKS.
Our book is intended for the gratification of boys. We know full well the intense delight taken by boys in risking their limbs or their lives, especially when such risk is accompanied with noise. Boys always have done so, and always will do so in spite of the very best of advice or precautions. As, therefore, it is impossible to keep them from making noises and endangering themselves, we have in the following pages endeavoured to show them how to make as much noise as possible with as little danger as possible.
What is there that makes the most noise and is most dangerous? Gunpowder, of course. Therefore, we have given descriptions of the best methods of employing this material, feeling quite sure that of accidents with gunpowder nine out of every ten are caused by ignorance. We knew a boy who lost the use of a thumb, and took all the skin off the palm of his right hand, by ignorant management of powder. He had read of blasting rocks, and nothing would satisfy him but blasting a bank. So he bored a deep hole in it with a stick, filled the hole with gunpowder, and then poked a lighted lucifer into the powder. The consequence was, that his face was so scorched as not to be recognised, all his eyebrows and eyelashes and most of his hair were burned off, while his right hand was injured as has been already mentioned. Now that boy had been studiously kept out of the way of powder by female relatives, and was naturally profoundly ignorant of its effects. Had he been taught to handle it, he would not now be forced to keep his right hand closed, or to write by holding the pen between the fingers of his clenched hand.
GUNPOWDER.
It will not be very advisable for the firework boy to make his own powder, but still it will not be amiss that he should know how it is prepared. Pulverise separately 5 drams of nitrate of potass, 1 dram of sulphur, and 1 dram of newly burnt charcoal, mix them together in a mortar with a little water, so as to make the compound into a dough, which roll out into round pieces of the thickness of a pin upon a slab. This must be done by moving a board backwards and forwards until the dough is of a proper size. When three or four of these pieces are ready put them together thus,—
and cut them off into small grains. Place these grains on a sheet of paper in a warm place where they will soon dry, but away from a fire. During granulation the dough must be prevented from sticking by using a little of the dry compound powder. This mode of granulation, though tedious, is the only one to be used for so small a quantity for the sake of experiment. In making powder in a large way it is granulated by passing the composition through sieves.
HOW TO MAKE TOUCH-PAPER.
Dissolve in a little spirits of wine or vinegar a little saltpetre, then take some purple or blue paper, and wet it with the above liquor and it will be fit for use. When pasting paper on any of the following works take care that the paste does not touch that part which is to burn. The method of using this paper is to cut it into slips long enough to go once round the mouth of a serpent, cracker, &c.
CASES FOR SQUIBS, FLOWER-POTS, ROCKETS, ROMAN CANDLES, ETC.
Procure a hard wooden cylinder, or, if possible, one made of metal, whose diameter corresponds with that of the interior of the proposed case. Roll round it several folds of cartridge paper, and paste the edges well, so that it may be held securely. Tie it round until dry.
TO CHOKE THE CASES.
When the cases are thus made they will require to be tied at the lower end. This is called choking them, and as much force is required it is necessary. Fix a wire into a small solid cylinder ([d]). Take another short piece ([b]) an inch or two long, with a hole up it to admit the other end of the wire, fit it on and pass it up the case. Then having fastened a piece of whipcord to a post, wind it round the part left hollow by the wire, which should be about half an inch from the end; pull it tight with the right hand and work the case round with the left. Cut out a piece of touch paper two inches long and an inch and a half broad, wind it round the choke, and tie it on with a piece of fine string—twist it to a point. The cases are best choked while damp.
COMPOSITION FOR SQUIBS, ETC.
Gunpowder half a pound, charcoal 1 ounce, brimstone 1 ounce, or in like proportion; grind them in a muller or pound them in a mortar. Or you may take 1 part steel filings, 1 charcoal, 1 sulphur, and 4 powder, which is a very good mixture, and can be rubbed together in a mortar.
HOW TO FILL THE CASES.
Your cases must be very dry when ready, and should be put into an iron or wooden mould; first put in a thimble full of your powder, and ram it down very hard with your ruler, then put in a little more till the case is full, ramming it down hard every time. If you have no mould, hold the case in your left hand with the twisted touch-paper downwards, and fill it after the same manner. When you have filled within an inch of the top, fill up this with loose powder not rammed, for a bang, and fold in the ends; after filling a dozen or two melt some pitch in a small ladle, and smear the ends of the case with it by means of a small brush.
TO MAKE CRACKERS.
Cut some stout cartridge-paper into pieces three inches and a half broad and one foot long, fold down one edge of these pieces lengthwise about three quarters of an inch broad, then fold the double edge down a quarter of an inch, and turn the single edge back half over the double fold. Open it, and lay all along the channel which is formed by the folding of the paper some meal powder, then fold it over and over till the paper is doubled up, rubbing it down at every turn; this being done bend it backwards and forwards two inches and a half, or thereabouts, at a time, as often as the paper will allow. Hold all these folds flat and close, and with a small pinching cord give one turn round the middle of the cracker and pinch it close; bind it with packthread as tight as you can, then in the place where it was pinched prime one end and cap it with touch-paper.
When these crackers are fired they will give a loud report at every turn of the paper; if you want a great number of these, you have only to cut the paper longer, or join it on to a greater length; but if they are made very long you must have a piece of wood with a groove in it deep enough to let in half the cracker, which will hold it straight while you are pinching it.
ROMAN CANDLES AND STARS.
These are best made with the following ingredients: 1 ounce of powder, 1 ounce of sulphur, and 2 ounces of nitre. Some persons, however, prefer 1 part sulphur, 1 charcoal, 1 iron filings, 4 of powder, and 8 of nitre. The composition being made, in filling the cases fill the contrary way to a squib—stop up the choke by driving down a piece of paper. Put in 1 quill of gunpowder loose and 1 star made in the following manner: 1 ounce of camphor, 1 of sulphur, 2 of meal powder, 1 ounce of the coloured fires, moisten them with oil of turpentine, and work them into little round balls. Having placed a star within the case, put in above it 3 quills of the composition, ram down, then powder, star, and composition alternately, till the case is full. Paste touch-paper round the top and twist to a point.
ROCKETS.
There are several recipes for making rockets, the best of which is 3 ounces of charcoal, 6 of sulphur, 8 of nitre, 32 of meal powder. Another very good one is, 3 ounces of iron filings, 4 of powdered charcoal, 8 of sulphur, 16 of nitre, and 64 of meal powder. If a smaller quantity is wanted divide each proportion by 2, if a still smaller divide by 4. In this [cut] s is the loose gunpowder with eight or ten stars upon it; c is that part of the rocket in which the composition is to be rammed hard, p the priming or quick match, t the touch paper. The cases are to be put into a mould and the composition must be well rammed. The cases should be four times the thickness of those for squibs.
RAINS.
Sometimes gold or silver rains are added to rockets, which give them a very beautiful appearance. A gold rain is made of 2 parts sawdust, 4 sulphur, 4 meal powder, 6 glass dust, 16 nitre, in all 32 parts. A silver rain may be made of 2 parts salt prunella, 8 sulphuret of antimony, 8 sulphur, 8 meal powder, and 14 nitre, in all 32 parts.
CATHERINE WHEELS.
These are very pretty fireworks, and are made to turn on a pivot. There are many recipes for the composition of which they are formed; 1 part camphor, 1 sulphur, 1 nitre, 2 meal powder. Another is, 3 parts iron filings, 4 sulphur, 12 nitre, 16 meal powder. This composition is to be rammed into small cases, and bound round a small wheel, having a hole for a pivot in the centre.
VARIOUS COLOURED FIRES.
The following recipes will give the young firework maker a great variety of the most beautiful fires. They should never be fired in a room, however, and always away from a dwelling.
CRIMSON FIRE.
The principal ingredient in this is nitrate of strontium, of which 40 parts are taken, with 13 of sulphur, 15 of chlorate of potass, 4 of sulphuret of antimony, and 2 of lamp-black. These, as all the ingredients for the other fires, should be rubbed in a ladle, and they may be used in a ladle or iron dish set on the ground.
BLUE FIRE.
The ingredients of blue fire are 20 parts; 12 of nitre, 4 of sulphur, 2 of sulphuret of antimony, and 2 of lamp-black.
GREEN FIRE.
The ingredients for green fire are in 54 parts; 42 of nitrate of barytes, 8 of sulphur, 3 of chlorate of potass, and 1 of lamp-black.
PURPLE FIRE.
The best recipe for purple fire is of 60 parts; 25 of nitre, 25 of nitrate of strontium, 7 of sulphur, 2 of realgor, and 1 of lamp-black.
WHITE FIRE.
The best and purest white fire is made of 24 parts of nitre, 7 of sulphur, 2 of red arsenic, and 1 of lamp-black.
SPUR FIRE.
9 parts of nitre, 4 of sulphur, and 3 of lamp-black, well rubbed together.
BLUE LIGHTS.
These are made of 4 parts of sulphur, 2 of nitre, and 1 of powder, and are rammed into squib-cases the contrary way.
PORT OR WILDFIRES.
Saltpetre 4 parts, meal powder 6 parts, and sulphur 3 parts. The composition to be moistened with linseed oil.
SLOW FIRE FOR WHEELS.
Saltpetre 4 parts, sulphur 2 parts, and meal powder 2 parts.
DEAD FIRE FOR WHEELS.
Saltpetre 5 parts, sulphur 1 part, lapis calaminaris 1 part, and antimony 1 part.
CAUTIONS.
Such are the principles and methods by which fireworks may be made; but we would advise our young friends to be very cautious, and never to attempt making any fireworks by candle-light; always to select some outhouse for their operations; to see that no iron or steel implements are about the place in which their fireworks are being manufactured, or they may go off before they wish it; to use wooden or brass implements in the bruising, grinding, and sifting of their mixtures; and never to bring the fireworks, or any of their ingredients, into the dwelling-house, or they may suddenly receive a
“Heavy blow and great discouragement.”
TO MAKE AN ILLUMINATED SPIRAL WHEEL.
Procure a circular horizontal wheel two feet in diameter with a hole quite through the nave, then take four thin pieces of deal three feet long each, and three-quarters of an inch broad each. One end of each of these pieces is to be nailed to the felloe of the wheel at an equal distance from one another; and the other end nailed to a block with a hole in its bottom, which must be perpendicular with that in the block of the wheel, but not so large. The wheel being thus made, a hoop planed down very thin must be nailed to the felloe of the wheel, and wound round the four sticks in a spiral line from the wheel to the block at the top; on the top of this block a case of Chinese fire must be fixed, and on the wheel any number of cases, which must incline downwards and burn two at a time. The axis of the wheel must be a little longer than the cone, and made very smooth at the top, on which the upper block is to turn and the whole weight of the wheel to rest. The entire framing of the wheel, with its connecting tubes, is shown in the above [cut].
THE GRAND VOLUTE.
Should my young friends wish to prepare a grand volute illuminated with a revolving wheel; the first step is to procure a large circular wheel, and on its rim lay as many four-ounce cases as will complete the circle, only allowing a sufficient distance between the cases that the fire may pass free, which may be done by cutting the upper part of the end of each a little shelving. On each spoke fix a four-ounce case about three inches from the rim of the wheel. These cases are to burn one at a time. On the front of the wheel form a spiral line with strong wire, on which tie port-fires, placing them on a slant with their mouths to face the same way as the cases on the wheel; all these port fires must be fired with the second cases of the wheel. Let there be a series of wooden spokes all made to screw into a block into the centre. When the large wheel begins to discharge the fireworks, the spiral wheel will of course revolve and produce a very beautiful illuminated cone.
A BRILLIANT YEW-TREE.
To prepare a brilliant yew-tree, a frame like the one represented in the [drawing] must be firmly attached to the ground. When the branches are fixed, place illuminating port-fires on the top of each, as many as is convenient; behind the top of the stem fasten a gerb or white fountain, which must be fired at the beginning of the illumination on the tree. A series of these, varying in the angular directions taken by the boughs, produce a very fine effect.
Such are a few general directions respecting the making of fireworks; but we have again to advise our young friends to be cautious of the gunpowder, and to keep away from the fire, or from a light, or from flames, steel, iron, or any other matter likely to cause a spark.
