HECTOGRAPH PADS AND INKS
The hectograph is a gelatin pad used for duplicating letters, etc., by transfer. The pad should have a tough elastic consistency, similar to that of a printer’s roller. The letter or sketch to be duplicated is written or traced on a sheet of heavy paper with an aniline ink (which has great tinctorial qualities). When dry this is laid, inked side down, on the pad and subjected to moderate and uniform pressure for a few minutes. It may then be removed, when a copy of the original will be found on the pad which has absorbed a large quantity of the ink. The blank sheets are laid one by one on the pad, subjected to moderate pressure over the whole surface with a wooden or rubber roller, or with the hand, and lifted off by taking hold of the corners and stripping them gently with an even movement. If this is done too quickly the composition may be torn. Each succeeding copy thus made will be a little fainter than its predecessor. From 40 to 60 legible copies may be made. When the operation is finished the surface of the pad should be gone over gently with a wet sponge and the remaining ink soaked out. The superfluous moisture is then carefully wiped off, when the pad will be ready for another operation.
The pad or hectograph is essentially a mixture of glue (gelatin) and glycerine. This mixture has the property of remaining soft yet firm for a long time and of absorbing and holding certain coloring matters in such a way as to give them up slowly or in layers, so to speak, on pressure.
Such a pad may be made by melting together 1 part of glue, 2 parts of water and 4 parts of glycerine (all by weight, of course), evaporating some of the water and tempering the mixture with more glue or glycerine if the season or climate require. The mass when of proper consistency, which can be ascertained by cooling a small portion, is poured into a shallow pan and allowed to set. Clean glue must be used or the mixture strained; and air bubbles should be removed by skimming the surface with a piece of card-board or similar appliance.
Variations of this formula have been proposed, some of which are appended:
| I.— | Glycerine | 12 ounces |
|---|---|---|
| Gelatin | 2 ounces | |
| Water | 7 1/2 ounces | |
| Sugar | 2 ounces | |
| II.— | Water | 10 ounces |
| Dextrin | 1 1/2 ounces | |
| Sugar | 2 ounces | |
| Gelatin | 15 ounces | |
| Glycerine | 15 ounces | |
| Zinc oxide | 1 1/2 ounces | |
| III.— | Gelatin | 10 ounces |
| Water | 40 ounces | |
| Glycerine | 120 ounces | |
| Barium sulphate | 8 ounces |
The Tokacs patent composition, besides the usual ingredients, such as gelatin, glycerine, sugar, and gum, contains soap, and can therefore be washed off much easier for new use. The smoothness of the surface is also increased, without showing more sticking capacity with the first impressions.
Hectograph Inks
Purple.—
| I.— | Methyl violet | 2 parts |
|---|---|---|
| Alcohol | 2 parts | |
| Sugar | 1 part | |
| Glycerine | 4 parts | |
| Water | 24 parts |
Dissolve the violet in the alcohol mixed with the glycerine; dissolve the sugar in the water; mix both solutions.
II.—A good purple hectograph ink is made as follows: Dissolve 1 part methyl violet in 8 parts of water and add 1 part of glycerine. Gently warm the solution for an hour, and add, when cool, 1/4 part alcohol. Or take methyl violet, 1 part; water, 7 parts; and glycerine, 2 parts.
Black.—
| Methyl violet | 10 parts |
| Nigrosin | 20 parts |
| Glycerine | 30 parts |
| Gum arabic | 5 parts |
| Alcohol | 60 parts |
Blue.—
| Resorcin blue M | 10 parts |
| Dilute acetic acid | 1 part |
| Water | 85 parts |
| Glycerine | 4 parts |
| Alcohol | 10 parts |
Dissolve by heat.
Red.—
| Fuchsin | 10 parts |
| Alcohol | 10 parts |
| Glycerine | 10 parts |
| Water | 50 parts |
Green.—
| Aniline green, water soluble | 15 parts |
| Glycerine | 10 parts |
| Water | 50 parts |
| Alcohol | 10 parts |
Repairing Hectographs.
HEMORRHOIDS: See Piles.
HERB VINEGAR: See Vinegar.
HIDES: See Leather.
HIDE BOUND: See Veterinary Formulas.
HIDE-CLEANING PROCESSES: See Cleaning Preparations and Methods.
HOARHOUND CANDY: See Confectionery.
HOARSENESS, CREAM BON-BONS FOR: See Confectionery.
HOARSENESS, REMEDY FOR: See Cough and Cold Mixtures and Turpentine.
Honey:
Honey Clarifier.
Detecting Dyed Honey.
HONEY WINE: See Mead.
HONING: See Whetstones.
HOOF SORES: See Veterinary Formulas.
HOP BITTER BEER: See Beverages.
HOP SYRUP: See Essences and Extracts.