and, if these directions have been observed, the farmer has a supply of bacon as good as the world can show. Some may prefer a “shorter cut” from the slaughter pen to the baking pan, and with their pyroligenous acid may scout the old-fashioned smoke as heathenish, and get their bacon ready for eating in two hours after the salt has struck in. But they never can show such bacon by their method as we can by ours. There is but one way to have this first-class bacon and ham, and that way is the one herein portrayed.
TO MAKE A SMOKEHOUSE FIREPROOF
as far as the stove ashes are concerned, is not necessarily an expensive job; all that is required is to lay up a row of brick across one end, also two or three feet back upon each side, connecting the sides with a row across the building, making it at least two feet high. As those who have a smokehouse use it nearly every year, that part can also be made safe from fire by the little arch built at the point shown in the illustration, Fig. [19]. The whole is laid up in mortar, and to add strength to the structure an iron rod or bar may be placed across the center of the bin and firmly imbedded in the mortar, two or three rows of brick from the top. Of course, the rear of the arch is also bricked up. In most cases, less than 250 brick will be all that is required.
FIG. 19. FIREPROOFING A SMOKEHOUSE.
A WELL ARRANGED SMOKEHOUSE.
A simple but satisfactory smokehouse is shown in the illustration, Fig. [20], and can be constructed on the farm at small cost. It is so arranged as to give direct action of smoke upon the meat within, and yet free from the annoyance that comes from entering a smoke-filled room to replenish the fire. The house is square, and of a size dependent upon the material one may have yearly to cure by smoke. For ordinary use, a house ten feet square will be ample. There are an entrance door on one side and a small window near the top that can be opened from the outside to quickly free the inside from the smoke when desired. At the bottom of one side is a small door, from which extends a small track to the center of the room. Upon this slides a square piece of plank, moved by an iron rod with a hook on one end. On the plank is placed an old iron kettle, Fig. [21], with four or five inches of earth in the bottom, and upon this is the fire to be built. The kettle can be slid to the center of the room with an iron rod and can be drawn to the small door at any time to replenish the fire without entering the smoky room or allowing the smoke to come out. The house has an earthen floor and a tight foundation of stone or brick. The walls should be of matched boarding and the roof shingled. The building is made more attractive in appearance if the latter is made slightly “dishing.”
| FIG. 20. FARM SMOKEHOUSE. | FIG. 21. FIRE, KETTLE AND TRACK. |