The modern, or rather more recent, method of heading the rocket with a clay diaphragm evidently suggested that the choking of the case might be dispensed with where the composition was less fierce, the necessary reduction of the orifice being produced by a clay diaphragm with a central hole of sufficient size. This method is followed with the gerb, fountains, and flower pot, and in the firework known to pyrotechnists as “fixt”; this unit is largely used in display work to form the fringe frame or lattice effect of a set piece. “Fixt” are made in 1 oz. and 2 oz. sizes, and contain a composition of approximately one part of steel filings to four of mealed gunpowder and finish with a bounce. The origin of the name is uncertain: it may refer to their use on fixed pieces in contradistinction to one revolving, or—as is most probable—was first used to distinguish between a fixed and a moving rocket.
The time of the introduction of the clay choke is uncertain. Jones, writing in 1765, although using clay in the heading of rockets, still choked all cases, but Mortimer (1824) uses it, although Ruggieri (1821), whilst doing the same, appears to think choking preferable.
The former gives instructions for charging the clay solid and boring the central hole; Ruggieri, however, uses a nipple like a much shortened rocket spindle, in which he agrees with the modern practice. This method is also utilised at the present time for small-sized rockets.
Of the fireworks of the fountain class, probably the first to develop from the crude rocket form were the gerb and flower pot. The gerb, or Chinese tree, contains a composition of saltpetre, sulphur, charcoal and iron borings, with the addition—if more force is required, as for instance to turn a device—of mealed gunpowder. Early makers used mealed powder alone and “iron sand,” or cast-iron reduced to powder by hammering. This composition is known as Chinese fire, and, as its name implies, was introduced into Europe from the East. An interesting article appeared in the “Universal Magazine” of 1764, written by a Jesuit missionary on the subject of Chinese fireworks. In it he describes the making of iron sand as follows:
“Old broken or useless pots serve generally for making this sand; they are broken into pieces of the breadth of the hand, after which, being made red-hot in the fire of a forge, they are thrown in that condition into a trough filled with fresh water, where they are left to cool. Thus calcined, the rust falls off in scales, and they are easily reduced into sand, being first broken into parcels of a finger’s breadth. The anvil and hammer used for this purpose must be also of cast-iron, because steel flats the grains of sand. It is necessary that the angles of those grains should be sharp, as it is the angles that form the flowers.”
The word “gerb” is derived from the French word meaning a sheaf of corn, and was first applied to water fountains.
The flower pot is charged with a composition formerly known as “spur-fire,” from the resemblance in form of its coruscations to the rowel of a spur. The effect produced is one of the most effective when successful, but has the disadvantage for display work that the effect is only appreciated at close quarters. The ingredients used are lampblack, sulphur, red arsenic, saltpetre, with sometimes the addition of charcoal and mealed gunpowder.
Of the smaller works of this division the squib and golden rain are too well known to need description. The squib and its variations have a choked case; the golden rain and similar works are left with an open bore.
Squibs are generally filled with a composition of sulphur, saltpetre and charcoal, sometimes steel filings, with a bounce of fine-grain powder.
A curious firework, now almost obsolete, for which it is difficult to find a class, is the five-pointed star. This work consisted of a case having a diaphragm of plaster of paris or clay above the filling, below which five holes are bored equidistant and at right angles to the axis. The case is fired in the unusual position of horizontal with the end towards the spectator, the fire playing all round the case, forming a star. The composition used was mealed powder, sulphur, saltpetre, and sulphuret of antimony. Ruggieri mentions this firework under the name “Etoile fixé,” and it is mentioned by Jones, writing in 1765, but not by Frézier.