BOILING BRINE
Boiling the brine improves it some, but not enough to pay for the extra trouble it makes. We recommend boiling the water, if one has the time, as it purifies it. When there is reason to believe that the water is impure, or when it is known to be tainted with vegetable matter, the brine should always be boiled, and the impurities will then float on the surface, and can be skimmed off.
CLEANSING CURING PACKAGES
(Copyrighted by B. Heller & Co.; Reprint Forbidden.)
All curing packages should be taken out of the cooler after the meat has been cured in them, and scalded and washed thoroughly clean with hot water and Ozo. Soda or Soda-ash may also be used, but we strongly recommend Ozo, which is a thoroughly reliable Washing Powder. When packages have been thoroughly cleaned, they should be put out in the sun and allowed to remain there for a day or two. The sun will thoroughly dry them and the fresh air will sweeten them.
SOME CAUSES FOR SOUR HAMS.
(Copyrighted; Reprint Forbidden.)
Sour Hams are sometimes caused by hanging warm meat in the same room in which the meat is cured. This should never be done. The warm carcasses raise the temperature of the curing room, thus causing the brine to get too warm. Under such conditions the meat is liable to sour in the brine. Furthermore, the brine is liable to absorb the odors from the warm carcasses, which of course is very objectionable.
Many suppose that Hams sour from getting too much smoke, but such is never the cause, as Hams will not sour from over-smoke. Smoke aids to preserve Hams and cannot cause them to sour. When Hams sour in the Smoke House the cause must be traced to the fact that they are not properly and fully cured before going into the Smoke House, and the portion that has not been thoroughly cured, which is generally close to the bone, has not been reached by the brine. In many cases, souring comes from imperfect chilling of meat before putting it into the brine; then again, the meat may not have been overhauled at the proper time and with the frequency which good curing requires.
In order to prevent souring of Hams the various stages of curing must be carried out with the utmost care. In the first place, hogs should not be killed when overheated or excited, and after they have been scalded and scraped, they must be dressed as quickly as possible, washed out thoroughly with clean water and then split and allowed to hang in a well ventilated room until partly cooled off. They should then be run into a cooler or chill room as quickly as possible and the temperature should be reduced to 32 to 34 degrees Fahrenheit. They should be allowed to thus chill for 48 hours. When hogs are properly chilled after curing, the temperature of the inside of the Ham or Shoulder will not be more than several degrees higher than the cooler. After being thoroughly chilled, the Hams must undergo the various processes which will be found in other pages of this book which give directions for the curing of Hams and Shoulders. When these directions are closely followed, there will never be trouble from sour Hams.
HAMS AND SUPERIOR HAMS.
(Copyrighted; Reprint Forbidden.)
