Woollen Table-Covers and Woollen Shawls, may be washed thus: Remove grease as before directed. If there be stains in the articles, take them out with spirits of hartshorn. Wash the things in two portions of hot suds, made of white soap. Do not wring them, but fold them and press the water out, catching it in a tub, under a table. Shake, stretch, and dry, neither by the sun nor a fire, and do not let them freeze, in drying. Sprinkle them three hours before ironing, and fold and roll them tight. Iron them heavily on the wrong side. Woollen yarn, should be washed in very hot water, putting in a teacupful of ley, and no soap, to half a pailful of water. Rinse till the water comes off clear.
New Black Worsted and Woollen Hose, should be soaked all night, and washed in hot suds, with beef's-gall, a tablespoonful to half a pail of water. Rinse till no color comes out. Iron on the wrong side.
To Cleanse Gentlemen's Broadcloths. The common mode, is, to shake, and brush the articles, and rip out linings and pockets; then to wash them in strong suds, adding a teacupful of ley, using white soap for light cloth; rolling and then pressing, instead of wringing, them; when dry, sprinkling them, and letting them lie all night; and ironing on the wrong side, or with a thin dark cloth over the article, until perfectly dry. But a far better way, which the writer has repeatedly tried, with unfailing success, is the following: Take one beef's-gall, half a pound of salæratus, and four gallons of warm water. Lay the article on a table, and scour it thoroughly, in every part, with a clothes-brush, dipped in this mixture. The collar of a coat, and the grease-spots, (previously marked by stitches of white thread,) must be repeatedly brushed. Then, take the article, and rinse it up and down in the mixture. Then, rinse it up and down in a tub of soft cold water. Then, without wringing or pressing, hang it to drain and dry. Fasten a coat up by the collar. When perfectly dry, it is sometimes the case, with coats, that nothing more is needed. In other cases, it is necessary to dampen the parts, which look wrinkled, with a sponge, and either pull them smooth, with the fingers, or press them with an iron, having a piece of bombazine, or thin woollen cloth, between the iron and the article.
To manufacture Ley, Soap, Starch, and other Articles used in Washing.
To make Ley. Provide a large tub, made of pine or ash, and set it on a form, so high, that a tub can stand under it. Make a hole, an inch in diameter, near the bottom, on one side. Lay bricks, inside, about this hole, and straw over them. To every seven bushels of ashes, add two gallons of unslacked lime, and throw in the ashes and lime in alternate layers. While putting in the ashes and lime, pour on boiling water, using three or four pailfuls. After this, add a pailful of cold soft water, once an hour, till all the ashes appear to be well soaked. Catch the drippings, in a tub, and try its strength with an egg. If the egg rise so as to show a circle as large as a ten cent piece, the strength is right; if it rise higher, the ley must be weakened by water; if not so high, the ashes are not good, and the whole process must be repeated, putting in fresh ashes, and running the weak ley through the new ashes, with some additional water. Quick-ley is made by pouring one gallon of boiling soft water on three quarts of ashes, and straining it. Oak ashes are best.
To make Soft-Soap. Save all drippings and fat, melt them, and set them away, in cakes. Some persons keep, for soap-grease, a half barrel, with weak ley in it, and a cover over it. To make soft-soap, take the proportion of one pailful of ley to three pounds of fat. Melt the fat, and pour in the ley, by degrees. Boil it steadily, through the day, till it is ropy. If not boiled enough, on cooling, it will turn to ley and sediment. While boiling, there should always be a little oil on the surface. If this does not appear, add more grease. If there is too much grease, on cooling, it will rise, and can be skimmed off. Try it, by cooling a small quantity. When it appears like gelly, on becoming cold, it is done. It must then be put in a cool place and often stirred.
To make cold Soft-Soap, melt thirty pounds of grease, put it in a barrel, add four pailfuls of strong ley, and stir it up thoroughly. Then gradually add more ley, till the barrel is nearly full, and the soap looks about right.
To make Potash-Soap, melt thirty-nine pounds of grease, and put it in a barrel. Take twenty-nine pounds of light ash-colored potash, (the reddish-colored will spoil the soap,) and pour hot water on it; then pour it off into the grease, stirring it well. Continue thus, till all the potash is melted. Add one pailful of cold water, stirring it a great deal, every day, till the barrel be full, and then it is done. This is the cheapest and best kind of soap. It is best to sell ashes and buy potash. The soap is better, if it stand a year before it is used; therefore make two barrels at once.
To make Hard White Soap, take fifteen pounds of lard, or suet; and, when boiling, add, slowly, five gallons of ley, mixed with one gallon of water. Cool a small portion; and, if no grease rise, it is done: if grease do rise, add ley, and boil till no grease rises. Then add three quarts of fine salt, and boil it; if this do not harden well, on cooling, add more salt. Cool it, and if it is to be perfumed, melt it next day, put in the perfume, and then run it in moulds, or cut it in cakes. Common Hard Soap, is made in the same way, by using common fat.
To manufacture Starch, cleanse a peck of unground wheat, and soak it, for several days, in soft water. When quite soft, remove the husks, with the hand, and the soft parts will settle. Pour off the water, and replace it, every day, with that which is fresh, stirring it well. When, after stirring and settling, the water is clear, it is done. Then strain off the water, and dry the starch, for several days, in the sun. If the water be permitted to remain too long, it sours, and the starch is poor. If the starch be not well dried, it grows musty.