The Cultivation and Manufacture of Tea

by Edward Money

By this I mean, so dividing it when first made into parts, that later the said parts shall be easily recognised, and separately or differently treated, as they may require it.

The usual custom is to begin at one end of a plantation, and dig it right through to the other. In the same way with the pruning and plucking, and I believe the system is a very bad one. Different portions of gardens require different treatment, inasmuch as they differ in soil, and otherwise. One part of a plantation is much more prolific of weeds than another—how absurd that it should be cleaned no oftener! This is only one exemplification of difference of treatment, but in many ways it is necessary, most of all in plucking leaf.

All parts of a plantation, owing in some places to the different ages of the plants, in others to the variety in the soil and its productive powers, in others to slopes or to aspect, do not yield leaf equally, that is, flush does not follow flush with equal rapidity. In some places (supposing each part to be picked when the flush is ready) seven days’ interval will exist between the flushes, in others nine, ten, or twelve; but no attention, as a rule, is paid to this. The pickers have finished the garden at the west end, the east end is again ready, and when done, the middle part will be taken in hand, be it ready or be it not! It may be that the middle part flushes quicker than any other; in this case the flush will be more than mature when it is taken, in fact it will have begun to harden; or it may be the middle part does not flush as quickly as the others; in this case it will be picked before it is ready, that is, when the flush is too young, and the yield will consequently be smaller.

I believe the yield of a plantation may be largely increased by attending to this. Every Tea estate should be divided into gardens of, say, about five to ten acres each.[15] If no natural division exists, small roads to act as such should be made. More than this cannot be done when the plantation is first laid out, but when later the plants yield, any difference between the productive powers of different parts of the same garden should be noted, and these divided off into sections. To do this latter with roads would take up too much space, and small masonry pillars, whitewashed, are the best. Four of these, one at each corner of a section, are enough, and they need not be more than 3 feet high and 1 foot square. Thus each garden may, where necessary, be divided into two sections, which, in a 300-acre estate, partitioned off into thirty gardens, would give about forty to sixty sections. No matter where a section may be, directly the flush on it is ready it should be picked. Where the soil on any one garden is much the same, and observation shows the plants all over it flush equally, it may be left all in one. I only lay down the principle, and I am very certain it works well, the proof of which is that, where I have practised it, some sections during the season give three, four, and five flushes more than others. Had the usual plan of picking from one end to the other been adopted, they would have been all forced to give the same number; in other words, the said extra flushes would have been lost, and further loss occasioned by some flushes being taken before they were ready, others after a portion of the tender leaf had hardened.

The best plan is simply to number the gardens from 1 upwards, and the sections in each garden the same way. Thus supposing No. 5 garden is divided into three sections, they will be known respectively as 5-1, 5-2, and 5-3. This is the best way for the natives, and I find they soon learn to designate each section. I have a man whose special duty (though he has other work also) it is to see each day which sections are ready to pick the following, and those, and those alone, are picked. Practice soon teaches the number of pickers required for any given number of sections, and that number only are put to the work. If a portion is not completed that day, it is the first taken in hand the next, and if any day on no sections is the flush ready, no leaf is picked the following.

Apart from leaf-picking, the garden and section plan detailed is useful in many ways. Each garden, if not each section which most requires it, is dug, pruned, or manured at the best time, and any spot on the plantation is easily designated. The plan facilitates the measurement of work, and enables correct lists of the flushes gathered to be kept. It is thus seen which gardens yield best, and the worst can, by extra manuring, be brought to equal those.

In short, the advantages are many, too numerous to detail.

Of course all this can be better done on a flat garden than on one planted on slopes, and though it may not be possible to work it out as much in detail on the latter, still a good deal in that way can be done, and I strongly recommend it.

In laying out a plantation keep it all as much together as possible, the more it is in one block the easier it is supervised, the cheaper it is worked. Still do not, with a view to this, take in any bad land, for bad land will never pay.

Let your lines of Tea plants, as far as practicable, run with geometrical regularity. You will later find, both in measuring work and picking leaf, great advantages therefrom. In gardens where the lines are not regular portions are continually being passed over in leaf-picking, and thereby not only is the present flush from such parts lost, but the following is also retarded.