When killed and cut up, begin immediately to salt them. Rub the outside of each ham with a tea-spoonful of powdered saltpetre, and the inside with a tea-spoonful of cayenne pepper. Having mixed together brown sugar and fine salt, in the proportion of a pound and a half of brown sugar to a quart of salt, rub the pork well with it. This quantity of sugar and salt will be sufficient for fifty pounds of meat. Have ready some large tubs, the bottoms sprinkled with salt, and lay the meat in the tubs with the skin downward. Put plenty of salt between each layer of meat. After it has lain eight days, take it out and wipe off all the salt, and wash the tubs. Make a pickle of soft water, equal quantities of salt and molasses, and a little saltpetre; allowing four ounces of saltpetre to two quarts of molasses and two quarts of salt, which is the proportion for fifty pounds of meat. The pickle must be strong enough to bear up an egg. Boil and skim it; and when it is cold, pour it over the meat, which must be turned every day and basted with the pickle. The hams should remain in the pickle at least four weeks; the shoulders and middlings of the bacon three weeks; and the jowls two weeks. They should then be taken out and smoked. Having washed off the pickle, before you smoke the meat, bury it, while wet, in a tub of bran. This will form a crust over it, and prevent evaporation of the juices. Let the smoke-house be ready to receive the meat immediately. Take it out of the tub after it has lain half an hour, and rub the bran evenly over it. Then hang it up to smoke with the small end downwards. The smoke-house should be dark and cool, and should stand alone, for the heat occasioned by an adjoining—building may spoil the meat, or produce insects. Keep up a good smoke all day, but have no blaze. Hickory is the best wood for a smoke-house fire, In three or four weeks the meat will be sufficiently smoked, and fit for use. During the process it should be occasionally taken down, examined, and hung up again. The best way of keeping hams is to wrap them in paper, or, to sew them in coarse cloths (which should be white-washed) and bury them in a barrel of hickory ashes. The ashes must be frequently changed.
An old ham will require longer to soak, and longer to boil than a new one.
Tongues may be cured in the above manner.
Boil some pigs’ livers. When cold, mince them, and season them with pepper, salt, and some sage and sweet marjoram rubbed fine. You may add some powdered cloves. Have ready some large skins nicely cleaned, and fill them with the mixture, tying up the ends securely. Prick them with a fork to prevent their bursting; put them into hot water, and boil them slowly for about an hour. They will require no farther cooking before you eat them. Keep them in stone jars closely covered. They are eaten cold at breakfast or supper, cut into slices an inch thick or more; or they may be cut into large pieces, and broiled or fried.
Having cleared it from the skin, sinews, and gristle, take six pounds of the lean of young fresh pork, and three pounds of the fat, and mince it all as fine as possible. Take some dried sage, pick off the leaves and rub them to powder, allowing three tea-spoonfuls to each pound of meat. Having mixed the fat and lean well together, and seasoned it with nine tea-spoonfuls of pepper, and the same quantity of salt, strew on the powdered sage, and mix the whole very well with your hands. Put it away in a stone jar, packing it down hard; and keep it closely covered. Set the jar in a cool dry place.
When you wish to use the sausage-meat, make it into flat cakes about an inch thick and the size of a dollar; dredge them with flour, and fry them in butter or dripping, over rather a slow fire, till they are well browned on both sides, and thoroughly done.
Sausages are seldom eaten except at breakfast.