CHAPTER VI. "DIRTY WORK FOR CLEAN MONEY"
If in the preceding chapter too much stress has been laid upon the smashing of our own boat and consequent sufferings, while little or no notice was taken of the kindred disaster to Mistah Jones' vessel, my excuse must be that the experience "filled me right up to the chin," as the mate concisely, if inelegantly, put it. Poor Goliath was indeed to be pitied, for his well-known luck and capacity as a whaleman seemed on this occasion to have quite deserted him. Not only had his boat been stove upon first getting on to the whale, but he hadn't even had a run for his money. It appeared that upon striking his whale, a small, lively cow, she had at once "settled," allowing the boat to run over her; but just as they were passing, she rose, gently enough, her pointed hump piercing the thin skin of half-inch cedar as if it had been cardboard. She settled again immediately, leaving a hole behind her a foot long by six inches wide, which effectually put a stop to all further fishing operations on the part of Goliath and his merry men for that day, at any rate. It was all so quiet, and so tame and so stupid, no wonder Mistah Jones felt savage. When Captain Slocum's fluent profanity flickered around him, including vehemently all he might be supposed to have any respect for, he did not even LOOK as if he would like to talk back; he only looked sick and tired of being himself.
The third mate, again, was of a different category altogether. He had distinguished himself by missing every opportunity of getting near a whale while there was a "loose" one about, and then "saving" the crew of Goliath's boat, who were really in no danger whatever. His iniquity was too great to be dealt with by mere bad language. He crept about like a homeless dog—much, I am afraid, to my secret glee, for I couldn't help remembering his untiring cruelty to the green hands on first leaving port.
In consequence of these little drawbacks we were not a very jovial crowd forrard or aft. Not that hilarity was ever particularly noticeable among us, but just now there was a very decided sense of wrong-doing over us all, and a general fear that each of us was about to pay the penalty due to some other delinquent. But fortunately there was work to be done. Oh, blessed work! how many awkward situations you have extricated people from! How many distracted brains have you soothed and restored, by your steady irresistible pressure of duty to be done and brooking of no delay!
The first thing to be done was to cut the whale's head off. This operation, involving the greatest amount of labour in the whole of the cutting in, was taken in hand by the first and second mates, who, armed with twelve-feet spades, took their station upon the stage, leaned over the handrail to steady themselves, and plunged their weapons vigorously down through the massive neck of the animal—if neck it could be said to have—following a well-defined crease in the blubber. At the same time the other officers passed a heavy chain sling around the long, narrow lower jaw, hooking one of the big cutting tackles into it, the "fall" of which was then taken to the windlass and hove tight, turning the whale on her back. A deep cut was then made on both sides of the rising jaw, the windlass was kept going, and gradually the whole of the throat was raised high enough for a hole to be cut through its mass, into which the strap of the second cutting tackle was inserted and secured by passing a huge toggle of oak through its eye. The second tackle was then hove taut, and the jaw, with a large piece of blubber attached, was cut off from the body with a boarding-knife, a tool not unlike a cutlass blade set into a three-foot-long wooden handle.
Upon being severed the whole piece swung easily inboard and was lowered on deck. The fast tackle was now hove upon while the third mate on the stage cut down diagonally into the blubber on the body, which the purchase ripped off in a broad strip or "blanket" about five feet wide and a foot thick. Meanwhile the other two officers carved away vigorously at the head, varying their labours by cutting a hole right through the snout. This when completed received a heavy chain for the purpose of securing the head. When the blubber had been about half stripped off the body, a halt was called in order that the work of cutting off the head might be finished, for it was a task of incredible difficulty. It was accomplished at last, and the mass floated astern by a stout rope, after which the windlass pawls clattered merrily, the "blankets" rose in quick succession, and were cut off and lowered into the square of the main batch or "blubber-room." A short time sufficed to strip off the whole of the body-blubber, and when at last the tail was reached, the backbone was cut through, the huge mass of flesh floating away to feed the innumerable scavengers of the sea. No sooner was the last of the blubber lowered into the hold than the hatches were put on and the head hauled up alongside. Both tackles were secured to it and all hands took to the windlass levers. This was a small cow whale of about thirty barrels, that is, yielding that amount of oil, so it was just possible to lift the entire head on board; but as it weighed as much as three full-grown elephants, it was indeed a heavy lift for even our united forces, trying our tackle to the utmost. The weather was very fine, and the ship rolled but little; even then, the strain upon the mast was terrific, and right glad was I when at last the immense cube of fat, flesh, and bone was eased inboard and gently lowered on deck.
As soon as it was secured the work of dividing it began. From the snout a triangular mass was cut, which was more than half pure spermaceti. This substance was contained in spongy cells held together by layers of dense white fibre, exceedingly tough and elastic, and called by the whalers "white-horse." The whole mass, or "junk" as it is called, was hauled away to the ship's side and firmly lashed to the bulwarks for the time being, so that it might not "take charge" of the deck during the rest of the operations.
The upper part of the head was now slit open lengthwise, disclosing an oblong cistern or "case" full of liquid spermaceti, clear as water. This was baled out with buckets into a tank, concreting as it cooled into a wax-like substance, bland and tasteless. There being now nothing more remaining about the skull of any value, the lashings were loosed, and the first leeward roll sent the great mass plunging overboard with a mighty splash. It sank like a stone, eagerly followed by a few small sharks that were hovering near.
As may be imagined, much oil was running about the deck, for so saturated was every part of the creature with it that it really gushed like water during the cutting-up process. None of it was allowed to run to waste, though, for the scupper-holes which drain the deck were all carefully plugged, and as soon as the "junk" had been dissected all the oil was carefully "squeegeed" up and poured into the try-pots.
Two men were now told off as "blubber-room men," whose duty it became to go below, and squeezing themselves in as best they could between the greasy masses of fat, cut it up into "horse-pieces" about eighteen inches long and six inches square. Doing this they became perfectly saturated with oil, as if they had taken a bath in a tank of it; for as the vessel rolled it was impossible to maintain a footing, and every fall was upon blubber running with oil. A machine of wonderful construction had been erected on deck in a kind of shallow trough about six feet long by four feet wide and a foot deep. At some remote period of time it had no doubt been looked upon as a triumph of ingenuity, a patent mincing machine. Its action was somewhat like that of a chaff-cutter, except that the knife was not attached to the wheel, and only rose and fell, since it was not required to cut right through the "horse-pieces" with which it was fed. It will be readily understood that in order to get the oil quickly out of the blubber, it needs to be sliced as thin as possible, but for convenience in handling the refuse (which is the only fuel used) it is not chopped up in small pieces, but every "horse-piece" is very deeply scored as it were, leaving a thin strip to hold the slices together. This then was the order of work. Two harpooners attended the try-pots, replenishing them with minced blubber from the hopper at the port side, and baling out the sufficiently boiled oil into the great cooling tank on the starboard. One officer superintended the mincing, another exercised a general supervision over all. There was no man at the wheel and no look-out, for the vessel was "hove-to" under two close-reefed topsails and fore-topmast-staysail, with the wheel lashed hard down. A look-out man was unnecessary, since we could not run anybody down, and if anybody ran us down, it would only be because all hands were asleep, for the glare of our try-works fire, to say nothing of the blazing cresset before mentioned, could have been seen for many miles. So we toiled watch and watch, six hours on and six off, the work never ceasing for an instant night or day. Though the work was hard and dirty, and the discomfort of being so continually wet through with oil great, there was only one thing dangerous about the whole business. That was the job of filling and shifting the huge casks of oil. Some of these were of enormous size, containing 350 gallons when full, and the work of moving them about the greasy deck of a rolling ship was attended with a terrible amount of risk. For only four men at most could get fair hold of a cask, and when she took it into her silly old hull to start rolling, just as we had got one half-way across the deck, with nothing to grip your feet, and the knowledge that one stumbling man would mean a sudden slide of the ton and a half weight, and a little heap of mangled corpses somewhere in the lee scuppers—well one always wanted to be very thankful when the lashings were safely passed.