These illustrations demonstrate the fact that the culture of sugar cane involves a constant struggle between science and unrestrained nature.
As a rule, Hawaiian sugar plantations are located close to the seacoast, between it and the base of the mountains. The lands slope gently toward the sea, thus insuring good drainage and easy application of water for irrigation. Most of the cane is grown on land less than five hundred feet above sea-level, although in a few rare instances it is cultivated at an elevation as great as three thousand feet. Parts of the leeward side of the islands, where it is extremely dry and hot, and where the cane thrives best, depend entirely on irrigation, the water being brought to the plantations by ditches or pumped from wells. On the windward side of the island of Hawaii, where the rainfall is abundant, irrigation is unnecessary except during very dry periods.
In cultivating, the ground is turned with steam ploughs to depths up to twenty-four inches. These ploughs are operated by powerful engines that work in pairs, one on each side of a field, usually from one thousand to fifteen hundred feet apart. One engine pulls a gang-plough across the field and the other draws it back. By this method the rich soil is thoroughly loosened and a wonderful vegetable growth results. Ordinarily in California the farmer ploughs only from four to six inches deep.
STEAM PLOUGH
PLANTING CANE
After the lands are ploughed and harrowed and all the weeds turned under, double mould-board ploughs are used to make the furrows in which the seed is planted. The furrows are not like those made for planting potatoes, but are about five feet apart and eighteen inches deep, each furrow and hill being symmetrical. They follow the contour of the land so that the irrigation water will fill the furrow and remain there until it is absorbed by the soil and penetrates to the cane roots. At regular intervals of about thirty-five feet, lateral ditches are cut, from which there is an entrance into every furrow. These lateral ditches deliver the water from the main ditches to the various parts of the fields. The land is now ready for the seed.
Meanwhile, the harvesting of the ripened cane in other fields is going on. As the laborers cut the cane, they top it, that is to say, they cut off about twelve inches of the upper part of the solid stalk. Sugar cane resembles bamboo, in that it is cylindrical in shape and divided every few inches into sections by rings or joints. In every joint there is a bud or eye, from which a shoot of cane will sprout, if properly planted in the ground and watered.
These tops, always cut from untasseled cane, contain very little sugar. They are carried to the newly prepared field and placed in rows in the furrows, end to end, lengthwise, the ends overlapping a trifle in order to guard against blank spaces in the growing cane. They are then covered, according to the season, with one to one and a half inches of earth, and the water is turned in until the furrow contains from three to four inches of water. Between six and ten days afterward, the little green cane shoots appear above the ground. From this time forward continuous irrigation and cultivation, together with proper fertilization, are required until the cane matures.