There are several methods of preparing cœruleum:—
(1) A solution of stannate of potash is added to one of cobalt. A blue precipitate is thrown down, which, on washing, becomes first light-red and then brown. When calcined at a white heat it assumes a blue colour.
(2) A solution of stannate of soda is mixed with a solution of nitrate of cobalt, and the resulting precipitate calcined to bright redness forms a blue pigment.
(3) Solutions of cobalt and tin are mixed and precipitated by soda, the precipitate washed free from soda being calcined as in all the other cases. The silicate of soda is the most satisfactory sodium salt for a precipitant.
Cobalt Blue.—This rich pure blue pigment is not alone permanent, but actually develops its full intensity only after exposure to the air. With age, however, it acquires a greenish tendency, and in artificial light it inclines to a violet tint. It is proof against acids and alkalies, and mixes particularly well with water. In combination with other pigments it is unaltered and has no effect on them. Its tones are different from those of ultramarine. It slowly decomposes when heated in strong sulphuric acid, yielding a violet solution and a white precipitate, which latter dissolves and affords a blue liquid on dilution with water. It consists principally of about 80 per cent. alumina, and 15 per cent. oxide of cobalt.
There are several ways of preparing it:—
(1) By Thénard’s original process, roasted cobalt, from Tunaberg, Sweden, is dissolved under heat in an excess of nitric acid. The solution, evaporated nearly to dryness, is boiled in water, and the deposit of arseniate of iron is filtered out. Into the filtrate is poured a solution of basic phosphate of soda, which throws down a precipitate of basic phosphate of cobalt, varying in hue from violet to pink. This precipitate is washed on a filter, and, while still gelatinous, 1 lb. of it is intimately mixed with 8 lb. of hydrated alumina, recently precipitated by ammonia from a solution of potash-alum. The mass is first dried to brittleness and then calcined in a covered clay vessel for half an hour at a cherry-red heat. The resultant blue pigment is stored in glass receptacles.
The preparation of the gelatinous alumina is conducted as follows. The potash-alum is dissolved in at least three times as much water as is necessary, and is then precipitated by an abundant excess of ammonia, with frequent stirring. When settled, the supernatant liquor is siphoned off, and the precipitate is thoroughly washed several times on a filter.
Thénard blue will vary in tint according to the proportions of alumina used. A pure colour is obtained with 4-5 parts alumina to 1 of phosphate of cobalt; a greenish hue with equal parts of alumina and cobalt salt; and almost any intermediate tone by varying the proportions between these limits.
(2) To 16 parts of gelatinous alumina add 1 part of arseniate of cobalt, obtained by precipitating the solution of cobalt by arseniate of potash.