Ammonium Citrate Solution on Phosphates.
| Substance. | Time of treatment. | Total phos. acid. Per cent. | Removed by official method. Per cent. | Removed by digester. Per cent. | |
|---|---|---|---|---|---|
| Steamed bone, | ½ | hour | 27.67 | 10.59 | 14.52 |
| 1 | “ | 12.21 | 14.82 | ||
| 2 | hours | 14.61 | 17.56 | ||
| 3½ | “ | 16.48 | 18.53 | ||
| 5 | “ | 17.94 | 20.22 | ||
| 7½ | “ | 18.99 | 20.25 | ||
| 10 | “ | 19.73 | 21.18 | ||
| Marl, | ½ | hour | 13.86 | 4.43 | 4.11 |
| 1 | “ | 8.28 | 6.82 | ||
| 2 | hours | 10.34 | 9.76 | ||
| 3½ | “ | 11.00 | 11.31 | ||
| 5 | “ | 11.80 | 11.83 | ||
| 8 | “ | 12.51 | 12.64 | ||
| 10 | “ | 12.58 | 13.00 | ||
| Acidulated bone, | ½ | hour | 19.38 | 12.09 | 12.28 |
| 1 | “ | 12.47 | 12.40 | ||
| 2 | hours | 12.20 | 12.43 | ||
| 3½ | “ | 12.40 | 12.24 | ||
| 5 | “ | 12.43 | 12.26 | ||
| Bone, | ½ | hour | 21.40 | 6.97 | 8.48 |
| Ammoniated dissolved bone, | ½ | “ | 18.22 | 9.28 | 10.63 |
| Cottonseed-meal and | |||||
| castor pomace, | ½ | “ | 2.52 | 0.23 | 0.25 |
| Phospho bone, | ¼ | “ | 16.55 | 7.06 | 7.21 |
In comparing duplicates, the results from the use of the digester are found to be subject to less variation than those from the usual method.
131. Huston’s Mechanical Stirrer.—The stirring apparatus shown in [Fig. 9] differs from those which have heretofore come into use, in requiring but a single belt to drive all the stirring rods, and in having all the parts protected from the laboratory fumes.[119] The details of the belt system are shown in the small diagram in the lower central part of the figure. The apparatus is mounted on a substantial wooden box, 200 centimeters long, thirty centimeters high, and eighteen centimeters wide. The driving pulleys, ten centimeters in diameter, are enclosed in the upper part of the case. The shafts on which these pulleys are mounted extend through the bottom of the enclosing box and carry a wooden disk, eleven centimeters in diameter, to prevent particles of foreign matter from falling into the beakers. The shafts extend two centimeters below these disks, and to the end of the shafts the bent stirring rods are attached by rubber tubing.
The board forming the support of the driving pulleys is extended two centimeters in front of the apparatus, and in this extension twelve notches are cut, in which are held the corks carrying the tubes which contain the solution to be used in precipitating the material in the beakers.
Figure. 9.
Huston’s Mechanical Stirrer.
The ends of these tubes are drawn out to a fine point so as to deliver the liquid at the rate of about one drop per second.
The front of the apparatus is hinged and permits the whole to be closed when not in use, or during the precipitation.