In using this paper, care must be taken to prevent the paste which is made use of, from touching any part, that is to burn. The method of using it, is by cutting it into slips, sufficiently long to go once round the mouth of a serpent, cracker, &c. When they are pasted on, be careful to leave a little above the mouth of the case not pasted; then prime with meal powder, and twist the paper to a point.
The mode of threading and joining leaders, and placing them on different works, we shall here describe. The observations of a writer in the Encyclopedia Britannica, vol. xv, p. 713, are pointed on this subject, which we will briefly notice. Joining and placing leaders, is a very essential part of fire-works; as it is on the leaders that the performance of all complex works depends. The works being prepared, and ready to be clothed, the pipes must be cut of a sufficient length to reach from one case to the other; and then put in the quick match, which must always be made to go in very easy. When the match is in, cut it off within about an inch of the end of the pipe, and let it project as much at the other end; then fasten the pipe to the mouth of each case, with a pin, and put the loose ends of the match into the mouths of the cases, with a little meal powder. This being done, paste over the mouth of each case, two or three bits of paper. This method is used for large cases.
The practice adopted for small cases, and for illuminations, is the following: First, thread a long pipe; then lay it on the tops of the cases, and cut a bit of the under side over the mouth of each case, so that the match may appear, and then pin the pipe to every other case, observing, before the pipes are put on, to put a little meal powder in the mouth of each case. If the cases, thus clothed, are port-fires on illuminated works, cover the mouth of each case, with a single paper; but if they are choaked cases, situated so, that a number of sparks from other works, may fall on them before they are fired, secure them with three or four papers, which must be pasted on very smooth, that there may be no creases for the sparks to lodge in, which often set fire to the works before their time. Avoid, as much as possible, placing the leaders too near, or one across the other, so as to touch; as it may happen, that the flash of one will fire the other. If the works should be so formed that the leaders must cross, or touch, they must be made very strong, and well secured at the joints, and at every opening.
When a great length of pipe is required, it must be made by joining several pipes, in the following manner: Having put on one length of match, as many pipes as it will hold, paste paper over every joint; but, if a still greater length is required, more pipe must be joined, by cutting about an inch off one side of each pipe near the end, laying the quick-match together, and tying them fast with a small twine; after which, cover the joining with pasted paper.
Leaders, or pipes of communication, are formed of paper, which is cut into slips three or four inches broad, so that, when it is rolled on the mandril or form, it may go three or four times round. When they are very thick, they are too strong for the paper which fastens them to the works, and will sometimes fly off without leading the fire. The forms for these leaders are made from two to six-sixteenths of an inch in diameter; but four-sixteenths is the size generally made use of. The forms are made of smooth brass wire; and, when used, they are to be rubbed over with grease, or wet with paste, to prevent their sticking to the paper, which must be pasted all over. In rolling of pipes, make use of a rolling board, but press it lightly. Having rolled a pipe, draw out the form with one hand, holding the pipe as light as possible with the other, and avoiding any unnecessary pressure. Leaders are made of different lengths; and, in cutting them, as is often the case, care must be taken to do it with as little waste as possible. Leaders for marron batteries must be made of strong cartridge paper.
The Etoupille of the French is the same as the former match; it being nothing more than a kind of quick-match, prepared by soaking three threads of cotton in a paste, composed of the best priming gunpowder and brandy. It is designed to communicate fire with promptness, from one part of a fire-work to another, and, therefore, has the same effect as the common cotton quick-match. The cotton is usually soaked, or steeped in a paste of gunpowder and brandy, neither too thick nor too thin, for the space of two hours, adding more of the brandy as it evaporates. In the French preparation, gum arabic is used, in the proportion of one ounce to a pound of powder. In the English preparation, isinglass, or fish glue is employed, in the proportion of four ounces dissolved in three pints of water. Gummy and gelatinous substances are calculated for no other purpose, than to make the powder adhere to the cotton, the quantity not being sufficient to retard the combustion of the match. Pipes or leaders of communication, are an essential part of fire-works, and hence great care and attention are required in preparing them. Cotton, prepared in the manner already described, is the substance generally made use of. It has the property of imbibing fluids with facility; and when spirit of wine, or brandy, or even water, is used, it absorbs, and mechanically combines with the gunpowder, the impregnation with which determines the quality of the match. Alcohol, deprived of as much water as possible, or, in other words, the most concentrated, appears to have an advantage over brandy or water. If it be used merely as a vehicle, in order to suspend the gunpowder, and likewise to carry it, as it were, into the fibres of the cotton, which appears to be its modus operandi, then it is undoubtedly preferable to either brandy or water. The former, as it never exceeds fourth proof, contains always a considerable quantity of water; and, therefore, as water decomposes gunpowder, by dissolving the nitre, and separating the sulphur and charcoal, on which it has no effect, it is obvious, that the gunpowder itself, when mixed with brandy, is more or less injured. It is true, however, that the cotton in that case would be more effectually saturated with the nitre; but it does not follow, that it would be saturated with the gunpowder; as two of its component parts, viz. the charcoal and sulphur, would be separated. We have seen, that touch paper is nothing more than paper, soaked in a solution of, and consequently impregnated with, nitre; but, in order to render a match more combustible, and convey fire with more rapidity, which is required in many cases, gunpowder is the only substance, that possesses this property in any degree.
The cotton, which is used for this purpose, is the same as that for candle wick, and, with respect to thickness, may be from one to six threads, according to the pipe, it is intended for. The pipe must always be large enough for the match, so that the match may be pushed in easily without breaking it. After it is doubled into as many strands as required, it is usually put into a flat bottomed copper, or earthen pan, and there boiled in a solution of saltpetre. It is then taken out, and coiled into another pan, and the remaining solution is poured on. Meal-powder is then put in, and pressed down, till it is quite wet. It is then wound upon a reel, keeping the hands moistened with the powder and fluid of the last kettle, and suffered to remain a short time; when it is taken down, and meal-powder sifted on both sides of it, till it appears quite dry. When dry, it is cut, and secured in skins.
There is one advantage in this process, that the cotton in the first place is saturated with nitre; and, in the second place, while still wet, is combined mechanically with the meal-powder. The match I apprehend, is in all respects equal to the etoupille of the French.
The priming paste, as it is called, consisting of meal-powder and brandy, may be preserved in close vessels for a length of time; and, when used, may be brought to a proper degree of consistency, to be worked, by the addition of more brandy.
The preparation of the etoupille, or match for communicating fire, will be given at large, when we treat of military fire-matches. It will be sufficient to remark, that its preparation, according to Bigot, (Traité d'Artifice de Guerre, p. 74), consists in macerating the cotton in vinegar, then pressing it, and steeping it in brandy, and afterwards working it in a paste, composed of meal-powder, gum arabic, camphor, and brandy, and then rolling it on a table with meal-powder.