The drying sheds ought to be built upon an elevated or dry spot, with a hoarded flour of rough split stuff, fifteen or eighteen inches from the ground, with apertures as windows to admit or to exclude the external atmosphere. In damp weather close all the doors and windows, also every night; in contrary weather open all.
In these drying houses the stalks should remain suspended until the vegetable moisture is entirely evaporated, so that on a dry day the stems of the leaves will break like a glass pipe, and the finer parts crumble into snuff upon compression; after which, in humid weather, they will become quite pliable; then strip the leaves off the stems, make them up into hands, and pack them tightly into a close bin: when full, cover it with boards and old bagged stuff, upon which place heavy weights. In this state it undergoes the sweating process, which, in this colony, is little understood or not properly attended to, and yet, upon the skill displayed thereon, the quality of the tobacco greatly depends. I will therefore give some general directions upon this portion of the planter's office. If the tobacco happen to be too damp when put into the bin, it will attain either an injurious or a destructive degree of heat; it must therefore he watched for some days after it is packed. To an experienced operator I would say, if the heat exceed 80 degrees of temperature, immediately unpack and re-hang the whole, waiting its condition as before explained, before it is again put into the sweating bin. Should the degree of heat be below that stated, it may remain for weeks or until the heat has subsided. I have generally removed it from the sweating process in about fourteen or twenty days, sometimes considerably longer, regulating that act by the odor and color of the leaf. If, however, it appears to be attaining a very dark brown color and its heat not subsided, it should be taken out and closely pressed into large cases or casks, when it will again attain a gentle heat called the "second sweating," as is invariably the case with the hogsheads of the American leaf tobacco: this again improves its quality. Here the grower's operations terminate.
It may be necessary to remark, that how skilful and experienced soever the grower may be, it is hardly possible for him to produce a good article upon a small scale; for with a less quantity than one ton to place in the sweating bin at a time, the requisite heat to insure success will not be generated. I would further observe, that the practice of the colonists in growing what they term a "second crop" is most injurious to their interests, their lands, and the quality and character of the colonial tobacco. The American planter never attempts it. I would therefore strongly recommend its discontinuance, and also never to crop one piece of land with tobacco more than two or three years in succession. The Americans rarely take more than two crops unless the land be new; after which they sow it down with grasses, in which state it remains for two or three years until it is again planted with tobacco. I would recommend this plan to the growers.
The character of the American tobacco has been greatly advanced in the mercantile world by an ordinance regulating that source of national wealth. The planters are thereby obligated to deposit their crops in warehouses, over which sworn inspectors preside, who rigidly examine every hogshead, and if found to be of mercantile quality, grant the owner a certificate, by which instrument only he sells his produce. The purchaser is hereby safe in buying these certificates. The tobacco to which they refer is delivered to the holder on presentation to the inspector. I mention this not as applicable here at present, but it most probably may hereafter.
When the colony is suffering severely for the want of labor, it may by some be deemed inopportune in offering remarks upon this article of commerce. To such dissentients I will remark, that a great portion of the work can be performed by women and children. A moiety of our anticipated increase of population will be available for this hitherto mismanaged source of wealth. At present the quantity grown in the colony is equal to three-fourths of its consumption, and which production is of a very inferior quality to the imported. These facts tend to show that my notice of the subject is not inopportune, and particularly so when the object is to point out those errors so generally adopted by the tobacco growers here. Years of practical experience, of personal observation upon the plantations of North America, and my having been, I believe, the grower of the greatest quantity of tobacco in the colony, qualify me to afford instructions thereon; whereby, if attended to, our tobacco will become fully equal to the American, as was proved to be the case by the crops I grew here (upwards of 40 tons),[56] which were sold in Sydney by the Commissariat Department at public auction, at an advance of twenty per cent. more than the imported leaf. As the duty on tobacco is about to be reduced, the present production may fall off, unless an immediate improvement in its quality take place. Instead of being importers of tobacco, we should, if it was grown here to perfection, be exporters of it to all our sister colonies; and in its raw state, also to the European markets. At present, for home consumption, there is a greater profit to be made by its cultivation, if skilfully managed, than in any part of the world; for the duty upon imported is a positive bonus to the grower.
In 1849-50 there were fifteen manufactories of tobacco on a small scale in New South Wales, but these were reduced in 1851 to six.
Many samples of tobacco grown in the colony have been pronounced by competent judges equal to Virginian, but a very considerable prejudice exists against it. There is, however, no doubt that the dealers dispose of a great deal as American tobacco, and get a best price for it. The reduction of the import duties on foreign tobacco, recently made by the Legislative Council, will probably retard the progress of the colonial production and manufacture of this article; but with an abundance of labor there is no question that this branch of industry will be again profitably resorted to. The quantity of tobacco manufactured in New South Wales, in 1847, was 1,321 cwt.; in 1848, 714 cwt.; in 1849, 2,758 cwt.; in 1850, 3,833 cwt.; in 1851, 4,841 cwt.
A correspondent of the Adelaide Observer recommends its culture in South Australia, and supplies the following useful information:—
Without entering into botanical details, I will simply state that the plant is of a shrubby nature, about five feet high, and ought not to be planted nearer than four feet from each other, in rows five feet apart—thus allowing for each plant a space of ground four feet by five, or 20 square feet. An acre will consequently furnish sufficient room for 2,178 plants.
The tobacco plant will thrive in almost any climate, from the torrid zone to the temperature of Great Britain. It luxuriates in rich alluvial valleys, where the soil is either of a loamy or a peaty nature.