Nevertheless, as this Acid combines most closely with water, and is in a manner strongly connected with it, the water carries up some portion thereof along with it; and hence it comes, that the liquor which rises into the receiver is acid: it is called Spirit of Vitriol.
As the fire carries off the most aqueous part, the other which remains in the retort increases in specific gravity. The Acid particles are brought nearer together, retain the aqueous particles more obstinately, and therefore to separate them the degree of heat must be increased.
It is usual to draw off one half or two thirds of the liquor that was put into the retort: but this depends on the degree of strength the Acid was of before concentration, and the degree of concentration intended to be given it.
If the Acid to be concentrated be Oil of Vitriol, from being brown or black it grows clearer as the operation advances, and at last becomes perfectly colourless and transparent; because the fat matter which tinged it black is dissipated during the process. Some of it deposites a white crystalline earth.
A sulphureous smell is generally perceived about the vessels in this operation. This arises from a small portion of the Phlogiston from which the Acid is not free; and it is this inflammable matter which gives the Oil of Vitriol its black colour: for the clearest and best rectified Oil of Vitriol will become brown, and even black, in a short time, if any inflammable matter, though in a very small quantity, be dissolved therein.
The vessels are luted in this operation, to prevent any loss of the Spirit of Vitriol, which being very acid is of use in many chymical experiments, and may itself also be again concentrated.
We observed, that in this operation it is necessary the retort should be of very good glass. Indeed the Acid is so active, and so strong, that if the glass be tender and have a little too much salt in its composition, it will be so corroded thereby that it will fall to pieces.
Though we directed the retort to be set in a sand-bath for this operation, it does not follow that it may not also be placed in a naked fire: on the contrary, when the heat is not conveyed through a bath the operation advances faster, and is much less tedious. But then great caution must be used, and the closest attention given to the management of the fire, which must be raised by almost imperceptible degrees, especially at the beginning of the operation; otherwise it is next to a certainty that the vessels will break. In general, a naked fire may be employed in almost all distillations which require a greater degree of heat than that of boiling water, or the balneum mariæ: the operation will be sooner finished; but it requires an experienced hand, that has by practice acquired a habit of governing the fire with judgment.
There is moreover another advantage in not using the sand-bath; which is, that if in the time of the operation you perceive the fire too fierce, you can quickly check it, either by stopping close all the apertures of the furnace, or by drawing out all or part of the lighted coals. This inconvenience is not near so easily remedied when you use the sand-bath; because when once heated it retains its heat very long after the fire is quite extinguished.