Figure 34.—Modified pistons after endurance run. U.S. Navy test, 1931. (Smithsonian photo A48325D.)
Combustion Chamber: In 1931 the contour of the cylinder head was changed slightly. This improved the combustion efficiency to the extent that the stroke of the fuel pumps could be decreased about 15 percent. The specific fuel consumption then decreased about 10 percent. In addition the compression ratio was reduced from 16:1 to 14:1.[20]
These changes were designed to eliminate smoke from the exhaust at cruising speed, and to reduce it at wide-open throttle.
Valves: A two-valve-per-cylinder model was built, but not put into production. It featured more horsepower (300), a higher rate of revolutions per minute (2000), and a better specific fuel consumption (about .35 lb/hp/hr).[21]
Capt. Woolson designed the production model with a single large valve for each cylinder. This was done in order to shorten the development period, for it is easier to design a single valve which serves both the intake and exhaust functions than one valve for each function. Not only are there fewer parts, but more important, there are no heat-dissipating problems. Although the single valve is heated when it releases the exhaust gases, it is immediately cooled by the incoming air of the next cycle. This cooling advantage is not shared by a valve which only passes exhaust gases.[22]
Cylinder Head: Ribs were added to increase its rigidity (compare fig. 32 with fig. 33).
Engine Size: A 400-hp model was developed in 1930. It was not put into production.[23]
Comments
Comments of Aeronautical Engineers: These comments appeared in Aviation for February 15, 1930, just a month before the Packard diesel received its approved-type certificate. They were in answer to the question, “What is your opinion of the probable early future of the compression ignition type of engine in aircraft powerplants?” Most of the engineers were enthusiastic about the diesel engine’s future in aviation; however, neither George J. Mead nor C. Fayette Taylor shared their colleagues’ opinions. Mead’s prophesy was accurate except for his discounting the diesel’s role in lighter-than-air craft. Taylor was correct in implying that there was a future for the diesel in powering airships.