The same process must be observed in running off peaches as in apples, except that the singling still ought not to be run so fast, nor so much fire kept under her, and more water used to prevent burning.
SECTION VI.
ARTICLE I.
The best method of setting Stills.
If stills are not set right, great injury may accrue to them, in burning and damaging the sides, singeing the whiskey, and wasting of fuel too, are not the only disadvantages; but more damage may be done in six months, than would pay a man of judgment for putting up twenty pair.
If they are set with their bottoms to the fire, they are very apt to burn, without the utmost care of the distiller, in stirring her when newly filled with cold beer, until she is warm, and by previously greasing the bottom well when empty. If wood be plenty, stills ought to be set on an arch, but if scarce, the bottom ought to be set to the fire. The following method is calculated for a furnace of either two or four feet long, and with the bottoms exposed, or on an arch as the distiller may fancy.
Make up a quantity of well worked mortar, composed of the greater proportion of good clay, a little lime and cut straw.
Lay the bottom of the furnace with flag stones, or good brick, from two to four feet long, as may be deemed most proper, let it be from twelve to sixteen inches wide, and from twelve to fourteen high. Then if it is designed to turn an arch, set the end of a brick on each wall of the furnace, leaning them over the furnace, till they meet in the middle—so continue the range on each side, until the furnace is completely covered in, leaving a small hole for the flue leading to the chimney behind, leaning towards the side, from which the flue is to be started, to proceed round the bilge of the still, which passage must be ten by four inches wide.