“6. The bars in front should be narrow.
“7. The chamber beneath the fire should be closed in front by a shield or economiser.
“There is one caution which should be given. There is no doubt about the fact that immediately beneath the fire the hearthstone is hotter, and the ashes remain much hotter when the ‘economiser’ is used. This may increase the risk of fire whenever wooden beams lie under the fireplace. In any case of doubt, the best plan would be to take up the hearthstone and examine, and relay with safe materials; but should this be impossible, safety may be secured by covering the hearthstone with a sufficient thickness of fire-brick, just within the space enclosed by the ‘economiser’—leaving a space of 2 or more in. between the fire-brick hearth and the bottom of the fire. In lighting the fire, if there be no cinders on which to build the fire, it is well to draw away the ‘economiser’ for a short time until the fire has got hold; but, if there be cinders left from the previous day, on the top of which the paper and wood can be placed, then the fire may be lighted with the ‘economizer’ in its place. There is a great art in mending a fire. It is wasteful to throw lumps of coal higgledy-piggledy on the fire. The red embers should be first broken up so as to make a level surface, then pieces of coal should be laid flat on the fire and fitted in almost like pavement; lastly, if the fire is intended to burn slowly and last very long, small coal should be laid on the top. An ‘economised’ fire so made will, in a short time, heat the coal through, and give off gases, which will ignite and burn brightly on the surface of the black mass, and when the gases are burnt off there is a large surface of red-hot coke.”
30. Kitchen Economiser. 31. Bedroom Economiser.
The annexed illustrations show the application of the economiser. Fig. 30 is a kitchen range, a being the economiser and b the front damper. The latter should always be used in warm weather, unless the front of the fire is needed for roasting and should be put on at night. Fig. 31 is a bedroom fireplace having fire-brick sides a, fire-brick back b leaning over the fire, narrow front bars c movable, grating d with narrow slits, chamber under the fire closed by economiser e, and front damper f which can close the lower ⅔ of the front of the fire at night or when a slow fire is needed.
The “economiser” is a shield of sheet iron which stands on the hearth, and rises as high as the lowest bar of the grate, against which it should fit accurately, so as to shut in the space or chamber under the fire. If the front of the range be curved or angular, as in most register stoves, the economiser will stand, owing to its shape—but if the front be straight, the economiser needs supports such as are shown. “Ordinary economisers” are made of 16-gauge charcoal iron plate, with ⅜ in. bright steel moulding at the top, ½ in. moulding at the bottom, and 1 or 2 knobs as required. “Kitchen economisers” are made of 16-gauge iron, with ½ in. semicircle iron at the top edge; and with supports in scroll form of ½ in. semicircle iron. Some makers use rather thinner iron plate and give strength by the mouldings. Some have used too thin plates, little better than tin, which have warped and so become more or less useless. Great care should be spent in taking the dimensions—as every grate has to be measured—as a foot for a boot. This renders it almost impossible to send orders to a maker by post. Some skilled person must take the measure, and take it accurately. The dimensions to be taken are: firstly, the outline of the bottom bar of the grate. If it be curved, or angular, the outline can be well taken by a piece of leaden gas-pipe, which, moulded to the outline can then be traced upon paper or carried carefully away to the makers; secondly, the height must be measured from the hearthstone to the bottom bar. This is the “economiser” in its simplest and cheapest form, as applicable to nearly every ordinary range.
Ornament can be added to taste. It is obvious that the adaptation of the economiser need not displace the old-fashioned ash-pan, and that the two can be combined, or that the economiser may be made like a drawer and catch the ashes. All such variations will work well, provided that the main principles be adhered to of “cutting off the under current,” and “keeping the chamber under the fire hot.” But the simplest form is the best.
