In addition to the data obtained by the various determinations, [Table 2] gives the relation between the results of the determinations for each individual sample. For instance, the ratio of pulp solids to filtrate solids (pulp solids divided by filtrate solids) varies in the different samples from 1.091 to 1.154, and, with the exception of two samples, it varies from 1.100 to 1.145. The average of the 33 samples was 1.12. The relation of insoluble solids to total solids (expressed as per cent of insoluble solids in total solids) is shown in Table 2. Considering the variations in the methods employed by different manufacturers in the preparation of tomato pulp, the per cent of insoluble solids in the total solids as shown by this column is closer than we might expect, varying in most of the samples from 11 to 14 per cent.
The per cent of sugar in the soluble solids, as shown by Table 2, varies in most of the samples from 50 to 55 per cent. This figure cannot be expected to be constant in different localities and in different years.
The acid, estimated as citric, constitutes in most of the samples from 9 to 10 per cent of the soluble solids.
Of especial interest is the refractive constant of the filtered liquor, shown in the last column of Table 2. The refractive constant of the various samples is much more uniform than might be expected from a product of this nature.
[Table 2] is chiefly interesting as affording the data from which [Tables 4] and [5] were calculated. The uniformity of the relations shown in [Table 5] is such that it is usually possible from one determination on the filtrate and the determination of solids in the pulp by drying to distinguish pulp made from whole tomatoes from that made from trimming stock. For instance, if the specific gravity or index of refraction of a filtrate prepared from a pulp of unknown origin, and the per cent of solids in the pulp by drying, do not agree approximately with the relation between these determinations as shown in [Table 5], it may be assumed that the sample was not prepared from whole tomatoes, or that some other substance, such as salt, has been added. Moreover, trimming stock pulp rarely conforms to the relations found in whole tomato pulp. For instance, the insoluble solids are usually higher and the acid lower in trimming stock pulp.
Trimming Stock Pulp
In [Table 3] are given the results of the examination of 21 typical samples of trimming stock pulp prepared at different plants and in different localities. This table is of especial interest in showing that the relations between the results of the various analytical determinations differ from those of whole tomato pulps as given in [Table 5]. For instance, in No. 1470 the immersion refractometer reading is 45.90, and the per cent of solids is 9.54, whereas, according to [Table 5], the per cent of solids in the pulp corresponding to an index of refraction of 45.90 should be 8.57. The specific gravity of the pulp is 1.0373, which, according to [Table 5], should correspond to 8.98 instead of 9.54. Of course it cannot be said definitely that a pulp which on examination is found to conform to all the relations shown in Table 5 is necessarily whole tomato pulp. It is entirely possible for an occasional sample of trimming stock pulp to conform to all the relations shown in that table; moreover, the extent to which different samples of trimming stock pulp will vary from the relations shown in [Table 5] differs with the manner of preparation. For instance, if a portion of the juice is discarded in the manufacture of trimming stock pulp, as is still the practice of some manufacturers, the variation from whole tomato pulp will be greater than otherwise and the variation will increase with the amount of juice discarded.
Methods of Analysis [2]
These methods may also be applied to the examination of raw tomatoes and canned tomatoes. In applying the relations given below to the results obtained by the examination of tomato pulp or canned tomatoes, it is assumed that no substance such as sugar or salt has been added. If salt is found to be present in excess of the amount normal to tomatoes (from 0.05 to 0.1 per cent), it is necessary to determine the amount and make correction therefor before applying the relations given below.
In examining raw tomatoes, care must be taken to secure a representative sample of the juice. This cannot be done by applying pressure directly, as the juice of the seed receptacles is of different composition from that of the fleshy part of the tomato. It is necessary, therefore, to crush the sample and thoroughly cook it in a flask surrounded by boiling water and connected with a reflux condenser.