Blanching is done to reduce the bulk of such foods as spinach and other greens, to render them partly sterilized, and to improve their flavor. It consists in dipping the food into boiling water or suspending it over live steam and allowing it to remain there for a longer period of time than is necessary for scalding. To blanch food, place it in a wire basket, a sieve, or a piece of clean cheesecloth and lower it into boiling water or suspend it above the water in a closely covered vessel. Allow it to remain there long enough to accomplish the purpose intended.
36. COLD DIPPING.--After the food to be canned is scalded or blanched, it is ready for cold-dipping. Cold-dipping is done partly to improve the color of the food. It stops the softening process at once, makes the food more firm and thus easier to handle, and helps to loosen the skin of foods that have been scalded. It also assists in destroying bacteria by suddenly shocking the spores after the application of heat. Cold-dipping, in conjunction with blanching or scalding, replaces the long process of fractional sterilization, and is what makes the one-period cold-pack method superior to this other process. To cold-dip food, simply plunge that which has just been scalded or blanched into cold water, as in Fig. 9, and then take it out at once.
37. PACKING THE JARS.--Packing the jars immediately follows cold-dipping, and it is work that should be done as rapidly as possible. Remove the jars from the hot water as they are needed and fill each with the cold-dipped fruit or vegetable. Pack the jars in an orderly manner and as solidly as possible with the aid of a spoon, as in Fig. 10. Just this little attention to detail not only will help to improve the appearance of the canned fruit, but will make it possible to put more food in the jars.
When a jar is filled, pour into it whatever liquid is to be used, as in Fig. 11. As has been stated, hot sirup is added for fruits and boiling water and salt for vegetables. However, when fruit is to be canned without sugar, only water is added. With tomatoes and some greens, no liquid need be used, because they contain a sufficient amount in themselves.
38. PREPARATION FOR THE WATER BATH.--As the jars are filled, they must be prepared for the water bath. Therefore, proceed to place the rubber and cover on the jar. Adjust the rubber, as shown in Fig. 12, so that it will be flat in place. Then put the cover, or lid, on as in Fig. 13, but do not tighten it. The cover must be loose enough to allow steam to escape during the boiling in the water bath and thus prevent the jar from bursting. If the cover screws on, as in the jar at the left, do not screw it down tight; merely turn it lightly until it stops without pressure being put upon it. If glass covers that fasten in place with the aid of a clamp are to be used, as in the jar at the right, simply push the wire over the cover and allow the clamp at the side to remain up. Jars of food so prepared are ready for processing.
