Storage of Home-Preserved Foods
by Ralph W. Johnston[17]
Proper storage of home-preserved foods, especially of home-canned products, and close scrutiny before serving are essential. If proper storage requirements are not met, home-preserved foods may lose their quality or spoil.
Homemakers should observe some simple techniques for checking home-canned foods before serving them. This will help prevent consumption of food that could cause the rare but extremely dangerous food poisoning called botulism.
Most canned foods are highly perishable yet do not require refrigeration until opened. Unlike frozen foods, they are unaffected by power interruptions or mechanical failures.
However, the hazard of botulism must always be kept in mind. Although botulism is rare, it results in a high death rate of about 65 percent among its victims. Yet it is an easy problem to avoid. Botulism results when home-canned foods are improperly processed. Under these conditions, the spore (a seed-like structure which is highly heat-resistant) of a soil bacterium called Clostridium botulinum may survive.
If the food product is low in acidity, as with peas, corn, or beans, the spore can germinate (sprout) and grow during storage at room temperatures. As Clostridium botulinum grows, it produces a powerful poison that when ingested can cause severe illness or death. Most cases of botulism in the United States stem from home-canned foods.
The home canner can avoid botulism primarily by following prescribed, reliable processing instructions such as those given in USDA Home and Garden Bulletin No. 8, Home Canning of Fruits and Vegetables. If you don’t have reliable processing instructions, don’t attempt home canning. If you have these instructions, read them before and during home canning and do not take short cuts or modify the instructions.
Do not use processing instructions of neighbors or relatives; although frequently given with the best of intentions, they may contain modifications that are inadequate and dangerous. Remember that past safe history of a relative’s processing procedure is no guarantee of future safety. Botulism doesn’t always occur even in inadequately processed home-canned foods.
After home-canned foods have cooled they are ready to be stored until needed. At this point, the home canner should make his first quality control and safety check, just as commercial canners do.
Jar lids should be examined. If the center of the lid is not depressed or is loose, refrigerate the product immediately and serve at the next meal. Before serving, boil low acid products for 10 minutes. Check all jars for cracks; if they are found, treat jars the same way as those with loose lids.
Observe cans for any evidence of leakage around seams; again if leakage is observed, refrigerate the cans immediately, serve at the next meal, and boil for 10 minutes before serving.
During this first integrity check on home-canned foods, it is unlikely that swelling of the cans or foaming in the jars will be noticeable, because of the short lapse of time since processing. But the first check can easily detect loose lids, cracked jars and leaking seams on cans.
The next step is to store home-canned products. Proper storage will protect the products from loss of quality and in some cases from spoilage. Store canned foods in a clean, cool, dry area away from bright light—particularly sunlight—and in an area where the foods will not freeze or be exposed to high temperatures. Under these conditions, the products will remain at high quality for at least a year.
Excessive dampness will rust cans or metal lids. If this condition becomes severe, leakage will occur and the product will spoil. Freezing causes expansion of the product and the jar lid may loosen, the jar may crack, or can seams may be stressed. This can lead to leakage and food spoilage.
When foods are preserved by heating, as in home canning or commercial canning, the heating process is designed to destroy all normal spoilage bacteria that can grow under usual storage conditions, and all bacteria capable of causing human harm. The products are called “commercially sterile” but are not always truly sterile.
A group of bacteria produce extremely heat-resistant spores that can only germinate and grow at high storage temperatures such as those above 103° F. These bacteria often survive both the home and commercial canning process. Even though present, they normally are of little concern from the viewpoint of spoilage and no concern at all from the standpoint of human health. However, if canned foods are stored in attics or near hot water pipes or in any other area where the temperature will exceed 102° F at any time, these heat-loving bacteria (called thermophilic) can grow and spoil the product.
Fred Farout
Boil home-canned low-acid foods 10 minutes before tasting or serving.
As a rule of thumb, home-canned foods will remain high in quality for one year if properly stored. After a year, loss of quality may occur.
Containers for home-preserved foods are designed to resist any chemical reactions between the product and the containers. However, some products—particularly high acid ones like tomatoes—will slowly react with the metal in the can or the jar lid. Corrosion and container failure may follow during subsequent storage. This action occurs from the inside out and can take place even under good storage conditions.
Jars should be dated when stored, and used within a year from the processing date. Always rotate stock on the shelves so as to use the oldest container first, and can no more units of any single product than you can use in a year.
The last and perhaps most important quality control steps are the final inspection and serving procedures.
After removing the product from storage, carefully inspect the container, and in the case of jars the visible contents. This should be done before opening.
If a can or jar lid shows any sign of swelling (bulging) or leakage of product, do not open the container. If a jar lid is loose or the contents of a jar are foamy or otherwise visibly abnormal, do not open. When any of these defects are noted, place the whole container in a heavy plastic bag and tie the top securely. Place this in doubled paper bags with heavy packing of newspapers. Tape or tie the top securely, place in a lidded garbage can, then wash your hands thoroughly.
Not all spoiled or leaking home-canned foods contain the deadly botulism toxin but some do, so extreme caution in disposal is necessary.
If a defective product is found, all of that product prepared at the same time should be removed from storage and similarly inspected.
Never taste the contents of a suspect product. Under certain circumstances, a spoonful of “off” unheated, suspect product has been known to kill.
Finally, bring all home-canned vegetables to a rolling boil after opening and before tasting. Heating makes any odor of spoilage more noticeable. Again, if an odor of spoilage is noted, destroy the product with caution. If the product is normal, cover the pan and continue to boil at least 10 minutes before serving. Only after these precautions are taken are home-canned vegetables safe to taste and serve.