—The term “molasses” is properly applied to the saccharine product which is separated from sugar in the process of manufacture. It is well to clearly discriminate in the use of the term in order that no confusion or misunderstanding may arise. To this end the terms “sirup” and “molasses” may be contrasted. A sirup is the direct product of the evaporation of the juice of a sugar-yielding plant or tree without the removal of any of the sugar. The term molasses applies to the same process with the exception of the fact that sugar has been removed at least partially by crystallization and some kind of mechanical separation of the crystals from the remaining liquid. Molasses, therefore, to use a term employed in chemistry, may be considered the “mother liquid” which has produced the crystallization of the sugar. The production of molasses has already been sufficiently described in the article on sugar making. The molasses is either separated by gravitation as in the old style of drying sugar or, as at the present time, almost exclusively by centrifugal action. The molasses naturally contains all the substances in solution or suspension which are not retained upon the gauze of the centrifugal. It differs from the total mass of evaporated sugar liquid only in the fact that a large portion of the sucrose or crystallizible sugar has been separated. The sugar juices of the cane and sorghum contain considerable quantities of sugar of a kind different from sucrose or common sugar, namely, an invert sugar, a “reducing sugar,” as it is called, which consists usually of about equal parts of dextrose and levulose. During the process of manufacture small portions of the sucrose are converted into sugar of this kind thus increasing its quantity. In the final crystallization there is always a portion of sugar uncrystallized remaining as a viscous liquid in contact with the crystallized particles. This natural invert sugar which is in the juice, the small portion formed from the sucrose during the process of manufacture, and the part of sucrose remaining uncrystallized in the mother liquid constitutes the molasses. In the washing of sugar the water which is used also passes into the molasses thus diluting it somewhat from its natural consistence. In the sugar refinery the molasses is made up of practically such materials as just mentioned, but inasmuch as the separation of the sugar is more complete the other portions of the molasses, namely, the mineral salts, particularly appear in a very much larger proportion than in the ordinary molasses as will be seen by the analysis of these bodies.
Varieties of Molasses.—New Orleans Molasses.
—The real New Orleans molasses is the product of the manufacture of sugar in the old-fashioned way in the open kettle and without the aid of vacuum pans. In this process the crystallization of the sugar does not take place during the boiling but the concentrated liquid is placed in tanks where the crystallization takes place. When this is complete it is broken up into small fragments and placed in a hogshead standing in an upright position, the bottom of which is perforated and covered with straw or fragments of sugar cane. When the hogshead is filled with the crystallized mixture, through the action of gravity the liquid portion gradually sinks and passes out at the bottom of the hogshead. This natural separation of the molasses makes a product of exquisite palatability and one of a character which it is difficult to equal even by the production of high-grade sirup. Before the Civil War this kind of molasses was used throughout the United States. At the present time only extremely small quantities of it are made inasmuch as the open kettle process is practically a lost industry in the South. The term “New Orleans molasses” as used at the present day, therefore, applies to a product of quite a different character.
Sugar Cane Molasses.
—Since the introduction of modern processes of making sugar, namely the vacuum pan and centrifugal process, the character of molasses from the sugar cane factory has constantly deteriorated. This is a natural deterioration due to the improvement in the method of sugar making. Much larger quantities of sugar are now obtained in a crystallized state than formerly. The molasses is to this extent impoverished and the impurities contained therein increased proportionately. It is quite common now in the process of manufacture of sugar from sugar cane to secure at least three crystallizations.
First Molasses.
—When the sugar is crystallized in the vacuum pans and separated from the molasses in the centrifugal the product which is obtained is called “first molasses.” Usually this molasses is diluted to a sirup and reboiled in connection with the clarified juices direct from the sugar cane and thus a second portion of sugar is obtained or the molasses may be boiled separately and a second crystallization of the sugar separated by the centrifugal. The molasses from this product is called “second molasses” and is inferior in quality to the first molasses.
Third Molasses.
—The second molasses is reboiled to a thick consistency and placed in wagons, transferred to a warm room where it is allowed to remain, sometimes for two or three months, when a third crystallization takes place. The sugar from this crystallization is separated as usual by the centrifugal, and a third molasses produced of still greater inferiority. Thus, in the best sugar factories high-grade molasses is not made in the United States but only that of inferior quality. This molasses is largely used for fermentation, or is fed to the mules on the plantations. It is also employed to a certain extent for mixing purposes as indicated above.