[187]But there is yet another Care to be taken of St. Foin Seed, besides the curing it; and that is, to keep it from Rats and Mice after ’tis cured; or else, if their Number be large, they will in a Winter eat up all the Seed of a considerable Quantity, leaving only empty Husks, which to the Eye appear the same as when the Seeds are in them. A Man cannot without Difficulty take a Seed out of its Husk; but the Vermin are so dextrous at it, that they will eat the Seed almost as fast out of the Husks, as if they were pulled out for them. I saw a Rat killed as he was running from an Heap of it, that had Seven peeled Seeds in his Mouth not swallowed; which is a Sign, that he was not long in taking them out. They take them out so cleverly, that the Hole in the Husk shuts itself up when the Seed is out of it. But, if you feel the Husk between your Finger and Thumb, you will find it empty. Also a Sackful of them is very light; yet there have been some so ignorant and incurious as to sow such empty Husks for several Years successively; and none coming up, they concluded their Land to be improper for St. Foin.
But of Seed thresh’d in the Field, without ever being wetted, if it be immediately winnow’d, and a single Bushel laid in an Heap, or put into a Sack, it will in few Days ferment to such a Degree, that the greatest Part of it will lose its vegetative Quality: The larger the Heap, the worse: During the Fermentation it will be very hot, and smell sour.
Many, to prevent this, spread it upon a Malt-Floor, turning it often; or, when the Quantity is small, upon a Barn-floor; but still I find, that this Way a great deal of it is spoil’d; for it will heat, tho’ it be spread but an handful thick, and they never spread it thinner: Besides, they may miss some Hours of the right times of turning it; for it must be done very often; it should be stirr’d in the Night as well as the Day, until the Heating be over; and yet, do what they can, it never will keep its Colour so bright as that which is well housed, well dry’d, and thresh’d in the Winter: For in the Barn the Stalks keep it hollow; there are few Ears or Seeds that touch one another; and the Spirits have room to fly off by Degrees, the Air entering to receive them.
The only Way I have found to imitate and equal this, is to winnow it from the Sheet; then lay a Layer of Wheat-straw (or if that be wanting, of very dry-thresh’d Hay); then spread thereon a thin Layer of Seed, and thus Stratum super Stratum, Six or Seven Feet high, and as much in Breath; then begin another Stack; let there be Straw enough, and do not tread on the Stacks; by this means the Seed mixing with the Straw, will be kept cool, and come out in the Spring with as green a Colour as when it was put in, and not one Seed of a Thousand will fail to grow when planted. A little Barn-room will contain a great Quantity in this Manner.
I have had above One hundred Quarters of clean Seed thus manag’d in one Bay of a small Barn. We do not stay to winnow it clean before we lay it up in the Straw; but only pass it through a large Sieve, and with the Van blow out the Chaff, and winnow it clean in the Spring.
This Field-threshing requires extraordinary fine Sun-shiny Weather, which some Summers do not afford at the Season, for threshing a great Quantity of it; for ’tis but a small Part of the Day in which the Seed can be thresh’d clean out. They who have a small Quantity of it, do carry it into a Barn early in the Morning, or even in the Night; whilst the Dew is on it; for then the Seed sticks fast to the Ear: As it dries, they thresh it out; and if they cure it well, have thus sometimes good Seed, but generally the Hay is spoil’d.
There is one Method of saving all the Seed good, and the Hay too, by carrying it unthresh’d to the Barn or Rick, in a particular Manner, tho’ it be a great Quantity, more than can presently be thresh’d; but must be laid up in Mows or Ricks, as Corn is. Then if it be carry’d in, in the Dews or Damp, the Hay is sure to be spoil’d, if not both Hay and Seed: When ’tis taken up dry, the Seed comes out with a Touch, and the greatest Part is lost in pitching up the Cocks, binding and jolting in carrying home.
To avoid this Dilemma, a Person who happen’d to have a great Crop of Seed on One hundred and Fifty Acres together (and being by Weather delay’d ’till Wheat-harvest came on, so that most Labourers went to Reaping) was forc’d to a Contrivance of getting it in as follows; viz. Three Waggons had each a Board with an Hole in, fix’d cross the Middle of each Waggon, by Iron Pins, to the Top of the Rades or Sides: There was a Crane which a Man could lift, and set into the Hole in the Board, and, having an Iron Gudgeon at the Bottom, which went into a Socket in the Bottom of the Waggon, would turn quite round: The Post of the Crane was Ten Feet Four Inches long, its Arm Four Feet Eight Inches long, brac’d; having a treble Pulley at the End of it, and another to answer it with an Hook.
About Forty Sheets were provided, capable of holding each One hundred and Fifty, or Two hundred Pounds Weight of it; these had Knots or Buttons at the Corners and Middles, made by sewing up a little Hay in these Knots, as big as Apples, into Part of the Sheet; for if any Buckle, or other thing, be sew’d to a Sheet plain, it will tear the Sheet. Half these Buttons have Strings ty’d to them; these Sheets are spread among the Cocks, fill’d by Two, and ty’d up by Two other Persons: There is also a light Fir Ladder, wide at Bottom, the Top of it fasten’d by a Piece of Cord to the brace of the Crane: they hitch the Hook of the lower Pulley to a fill’d Sheet, and by a little Horse at the End of the Pulley-rope, draw it up sliding on the Ladder; ’tis up in a Moment: Then the Man who is below, hitches the Crook of the Pulley to the lower Round of the Ladder, and the Loader above pulls up the Ladder from the Ground, till the Waggon comes to another Sheet. The Waggons are lengthen’d by Cart-Ladders before and behind, for the more easy placing of the Sheets. When about Twelve or Fifteen of them are loaded, they have a Rope fix’d to the Fore-part of each Waggon, which they bring over the Top of all the loaded Sheets, and wrest it at the Tail, to hold on the Sheets fast from falling off with Jolting. Then the Loader pulls out the Crane, and puts it into the next Waggon in the same Manner. One Waggon is loading whilst another is emptying in the Barn, by treble Pulleys likewise; because ’tis inconvenient to take it out of the Sheets by Prongs; but the Pulleys will easily draw off Two or Three Sheets together. One Waggon is always going to the Field, or coming home. This Contrivance makes more Expedition than one would imagine: Three Loads have been loaded, and sent off, in the same Time this way, that one Load of Hay has been loading, binding, and raking off the Outsides of it, in the next Ground, in the common Way.
I will not relate the manner of making a Rick of this Seed in its Hay, of monstrous Dimensions, by a sort of Mast-pole Forty-four Feet high, with a Ten Feet Crane at the Top, which made the same Expedition; because I think, that where such a Quantity is, Dutch Barns with moving Roofs are better. Such a Rick is troublesome to thatch, and the Wind has more Power to blow the Thatch off so high in the Air, than if it were lower. Neither would I advise any one to reserve much more St. Foin for Threshing, than his Barn will contain; because tho’ sometimes it brings the greatest Profit by Threshing, yet some Years ’tis apt to be blighted.